Ram 5500 Body Problems
39 owner complaints filed with NHTSA across 10 model years.
Complaints by Year
Worst year: 2016. Best year: 2021.
Owner Reports
A representative sample of complaints filed with NHTSA.
Our driver told us that he lost steering. At 35 mph on a open highway (which is confirmed by our gps). He also has a clean driving record and has been driving box truck for decades with no incident. Once steering was lost the box truck t...
Took the truck to the ram dealership to get the recall for the rear wheel studs replaced they did the job a few days later the wheel almost came off on the freeway. The mechanic didn’t tighten the lug nuts we caught it just in time bef...
The contact owns a 2016 Ram 5500. The contact stated that while driving at approximately 15 MPH the driver's side rear outer wheel suddenly detached from the vehicle. Upon inspection, it was discovered that all ten lug nuts securing the ...
The contact owns a 2016 Ram 5500. The contact stated while driving approximately 15 MPH and making a left turn the dual left rear tires had separated from the vehicle and the vehicle landed on the axle. The contact stated no warning ligh...
2020 DODGE RAM 5500. CONSUMER WRITES IN REGARDS TO Y26 STUDS SAFETY RECALL. CONSUMER WOULD LIKE TO KNOW WHEN PARTS WILL BE AVAILABLE TO PERFORM THIS RECALL. THE CONSUMER STATED THE VEHICLE HAD AN EXHAUST FIRE. THE VEHICLE SMOKED FOR 20...
I PARKED MY TRUCK AND TURNED IT OFF. WENT INSIDE AND ABOUT 15 MINUTES LATER MY TRUCK ROLLED DOWN A HILL AND WENT ACROSS A BUSY ROUTE 15 . THE TRUCK WAS STILL IN PARK AND THE ENGINE WAS OFF AND THE WHEEL WAS STILL LOCKED AT THE BOTTOM. IT...
2014 RAM 5500 DIESEL PURCHASED NEW IN APRIL 2015 FIRE UNDER HOOD ON MAY 30, 2017. NO LIGHTS CAME ON AS THE SENSORS WERE BURNED OUT AS WELL AS THE ALTERNATOR, THE HARNESSES AND OTHER PARTS UNDER THE HOOD. THE TRUCK WAS IN MOTION BUT FLA...
While unloading cargo, I was standing on the flatbed of the truck, leaning over the standing side-gates, without realizing they weren’t locked in place. The gates fell down onto a co-worker and I fell out of the truck. Similar inciden...
The contact owns a 2020 Ram 5500. The contact stated that while driving at 20-25 MPH, the dual wheel tires detached from the vehicle and struck another vehicle. On another occasion while driving 60 MPH, the tires detached. There was no w...
While traveling on a highway at speeds in excess of 50mph the 2015 Ram 5500 lost the rear set of dual tires on the passenger side. The wheels came off after all 10-wheel studs failed and broke off. This is the second incident on this sam...
The contact owns a 2019 Ram 5500. The contact stated that while one of his drivers was driving at an undisclosed speed, the tire tread detached and began to roll down the highway. The driver pulled over to the side of the road. There was...
This is a 2022 Dodge Ram 5500. The wheel studs broke off while driving on the interstate, and the dually tires came off. This is a major safety issue and the driver had a narrow escape. This same issue persisted through the 2012-2021 mod...