Bmw 540i Electrical Problems
34 owner complaints filed with NHTSA across 4 model years.
Complaints by Year
Worst year: 2000. Best year: 2024.
Owner Reports
A representative sample of complaints filed with NHTSA.
TL* THE CONTACT OWNS A 2000 BMW 540I. THE CONTACT STATED THAT THE BRAKE LIGHTS REMAINED ILLUMINATED, CAUSING THEM TO OVERHEAT AND MELT THE CASING. THE VEHICLE WAS TAKEN TO THE DEALER WHERE THE TECHNICIAN ADVISED THAT THE VEHICLE WAS NOT ...
TL* THE CONTACT OWNS A 2000 BMW 540I. THE CONTACT WAS DRIVING APPROXIMATELY 60 MPH WHEN ROAD DEBRIS CRASHED INTO THE FRONT DRIVER SIDE DOOR AND THE FRONT DRIVER SIDE AIR BAG DEPLOYED. THE VEHICLE WAS PULLED OVER AND SHUT OFF. A POLICE R...
NOTE: CAR COULD BE DRIVEN AFTER AIRBAG WENT OFF. ENGINE TURNED OFF WHEN BAG RELEASED.*AK
The contact owns a 2001 BMW 540i. The contact received notification of NHTSA Campaign Number: (17V047000 (AIR BAGS) and would like to be removed from the recall distribution list. The local dealer and manufacturer were contacted.
The audio suddenly stops and my turn signals also stop working. When this happens when I'm in traffic, this is very frightening because I cannot signal lane changes or turns. Turning off the ignition and restarting the car always fixes ...
Daytime running lights are dim or discolored. SIB 63 04 was issued acknowledging the problem, however repairs are only covered under the new vehicle warranty. In most cases, the issue occurs after the new vehicle warranty has expired.
Car had sat for about a week since I had driven it. I opened the driver door, inserted the key, and turned the key to the starting position. It failed to crank after the dash lights lit up and then the driver steering wheel airbag deploy...
The contact owns a 2001 BMW 540I. The contact stated that the dealer had previously performed an unknown air bag recall repair; however, the failure occurred a year after the recall repair was performed. The contact stated that while the...
Passenger Restraint System error in BMW seems to be a common problem. This should be looked over for a recall issue.
Passenger seat in 2017 BMW 5 series cars have a well known and not covered fault where in a loud chiming will go off requiring the passenger seatbelt to be buckled. This chime does not stop and continues until the seat belt is buckled. ...
POSSIBLE TAKATA INFLATOR: AT FIRST THE PASSENGER AIRBAG LIGHT CAME ON OCCASIONALLY AND NOW THE PASSENGER AIRBAG LIGHT IS ON ALL AT THE TIME.
WIRING HARNESS IN LOOM AT CONNECTION BETWEEN BODY AND TRUNK LID IS SHOWING CRACKED WIRES WHICH CAN LEAD TO A VARIETY OF SYMPTOMS WHEN WIRES SHORT. TRUNK WILL ONLY OPEN MANUALLY WITH KEY. KEY FOB REMOTE AND INSIDE VEHICLE TRUNK RELEASE ...