Ford Bronco Transmission Problems

My drive shaft/coupling caught fire at the front transfer case. I was able to extinguish it safely. This is the same description as: NHTSA Recall No.: 26V236 Manufacturer Recall No.: 26S26 And the description “ Vehicle 1: 2021-2025 FO...

Differential carrier replacement due to metal contmination being found in differential during oil change and a transmission overhaul due to excessive wear of(clutch container, CDF bushing, forward hub and front support bushings). They al...

1. Component/system that failed/malfunctioned — Braking system (electronic parking brake and brake control modules) combined with electrical/communication defect preventing storage of diagnostic trouble codes (DTCs). Vehicle available ...

The contact owns a 2023 Ford Bronco. The contact stated that while driving a motorhome at an undisclosed speed and towing the vehicle in tow mode, the transmission blew up. The contact pulled over to retrieve sunglasses from the vehicle ...

I’ve complained to my local Ford dealer about 10-speed transmission issues including to several different service techs. There is a loud clunk and physical movement of the vehicle when shifting from park through to reverse and eventual...

The contact owns a 2024 Ford Bronco. The contact stated that while driving at an undisclosed speed, the "Pre-Collision System Fault Detected" message was displayed. The vehicle returned to normal functionality, but the failure became a r...

My 2022 Manual transmission has been making a scraping sound when cold since I bought it. I've had 2 dealerships not do anything about it and I feel for paying $65,000 for a vehicle, it shouldn't be making this noise and it could be a sa...

The contact owns a 2022 Ford Bronco. The contact stated that while driving at undisclosed speeds, the “Powertrain Malfunction - Reduced Power Fault” message was displayed and flickered on and off. The contact that the battery was los...

Vehicle was shifted into 4L on a relative flat surface. Vehicle would not indicate successful transfer to 4L, just a blinking 4L indicator light and then a message to place vehicle in N and then pull forward. After unsuccessful attempt ...

UNKNOWN grinding sound when at idle or in/out of gear ( manual transmission) sounds like transfer case. Other owners of 2021-2023 broncos regardless of trim levels have heard this sound with their broncos as well (manual trans)

The left front driveshaft is a problem. Had a 2022 Ford Bronco and Ford did a RAV Lemon law. Bought a 2024 and now the same problem is happening again. Same issues and 800 miles on a new Bronco. Also on m 2022 had the hard top replaced 5...

Front pinion seal leak is detected at where the front drive shaft meets the front differential. Ford attempted to fix it with a pinion seal replacement and the leak is still unresolved, second attempt was done by changing the front diffe...