2004 Suzuki Recalls
10 NHTSA recall campaigns covering 4 models.
Suzuki GSX-R600 · 2004
Suzuki Motor of America, Inc. (Suzuki) is recalling certain model year 2004-2013 GSX-R600 and GSX-R750, and model year 2005-2013 GSX-R1000 motorcycles. In combination with older brake fluid, corrosion of the brake piston inside of the front brake master cylinder generates gas...
Consequence: As a result, front braking power may be reduced increasing the risk of a crash.
Suzuki Verona · 2004
Suzuki Motor of America, Inc. (Suzuki) is recalling certain model year 2004-2006 Verona vehicles manufactured June 2003 to October 2005. In the affected vehicles, there may be heat generated within the DRL module located in the instrument panel, which could melt the DRL module.
Consequence: If the DRL module melts due to the heat generation, it could cause a vehicle fire.
Suzuki Verona · 2004
IN CERTAIN PASSENGER VEHICLES, A FAULT IN THE ADAPTIVE FUEL CONTROL LOGIC CAN CAUSE SOME VEHICLES TO USE AIR/FUEL RATIOS DURING DECELERATION THAT ARE LEAN ENOUGH TO CAUSE ENGINE STALLING.
Consequence: ENGINE STALLING COULD RESULT IN A CRASH.
Suzuki Forenza · 2004
ON CERTAIN PASSENGER VEHICLES, HEADLAMP LOW BEAM OR DAYTIME RUNNING LIGHT (DRL) FUNCTION MAY BE INOPERATIVE DUE TO A MELTED SPLICE PACK ON THE WIRING HARNESS.
Consequence: INAPPROPRIATE LIGHTING COULD REDUCE VISIBILITY OF VEHICLES AND INCREASE THE POTENTIAL FOR A CRASH.
Suzuki Forenza · 2004
Suzuki is recalling certain model year 2004-2006 Forenza and model year 2005-2006 Reno vehicles manufactured from September 23, 2003, through March 7, 2006. Increased resistance due to poor contact between the terminals of certain wires can generate heat that can melt the spl...
Consequence: If the headlamps fail to function, this will lead to reduced driver visibility, increasing the risk of a crash.
Suzuki Forenza · 2004
Suzuki Motor of America, Inc. (Suzuki) is recalling certain model year 2004-2008 Forenza vehicles, and 2005-2008 Reno vehicles manufactured from September 1, 2003, through July 30, 2008. In the affected vehicles, heat may be generated in the headlamp switch or daytime running...
Consequence: If the heat generated within the headlamp switch or DRL module located on the left side of the steering column melts the headlamp switch or DRL module, there is an increased ris...
Suzuki Forenza · 2004
ON CERTAIN PASSENGER VEHICLES, THE BRAKE LIGHT SWITCH MAY BECOME MISADJUSTED IF AN UPWARD/REARWARD FORCE IS APPLIED TO THE BRAKE PEDAL. IF THIS SHOULD OCCUR, THE BRAKE LIGHT SWITCH WILL NOT FUNCTION PROPERLY, CAUSING THE BRAKE LIGHTS, INCLUDING THE HIGH MOUNTED STOP LAMP, TO ...
Consequence: IF THE BRAKE LIGHTS REMAIN ON CONTINUOUSLY WHILE DRIVING,A FOLLOWING DRIVER MAY NOT KNOW WHEN YOUR BRAKES HAVE BEEN APPLIED, AND A REAR-END CRASH COULD OCCUR WITHOUT PRIOR WARNI...
Suzuki Forenza · 2004
ON CERTAIN PASSENGER CARS, THE DUAL STAGE DRIVER'S AIR BAG DEPLOYS IN AN IMPROPER SEQUENCE.
Consequence: IF THE DRIVER'S AIR BAG DEPLOYS IMPROPERLY DURING A FRONTAL VEHICLE CRASH, THE DRIVER COULD BE SEVERELY INJURED OR KILLED.
Suzuki AN400 · 2004
ON CERTAIN SCOOTERS, IF THE IGNITION SWITCH IS NOT FULLY TURNED FROM THE 'OFF' TO THE 'ON' POSITION, THERE MAY BE UNSTABLE CONTACT BETWEEN THE IGNITION SWITCH CONTACTS. THIS CAN CAUSE ARCING IN THE IGNITION SWITCH.
Consequence: HEAT FROM THE ARCING CAN MELT THE INTERNAL SWITCH BASE PLATE. IF THE SCOOTER IS RIDDEN IN THIS CONDITION, THE IGNITION SWITCH MAY FAIL. IF THIS HAPPENS, THE ENGINE WILL STALL,...
Suzuki Verona · 2004
CERTAIN PASSENGER VEHICLES MAY HAVE A MISLOCATED SENSOR IN THE DRIVER'S SEAT BELT BUCKLE ASSEMBLY. THIS CONDITION CAN PREVENT THE DRIVER'S SEAT BELT TONGUE FROM BEING INSERTED INTO THE BUCKLE.
Consequence: IN THE EVENT OF A CRASH, A SEAT OCCUPANT MAY NOT BE PROPERLY RESTRAINED INCREASING THE RISK OF INJURY.