2003 Audi Allroad

During recent heavy rains, all of a sudden the car's transmission that had been working fine, after having been parked briefly pointing slightly down hill, no longer functioned properly, and had apparently gone into "LIMP Mode". after talking with Mechanics and doing research, we checked the carpet areas and determined and documented the car's interior was very wet, both in front and in the rear areas, with evident moisture and corrosion under the battery and cabin air filter areas and rear wheel well area. The Transmission no longer shifts properly and the car is not able to be safely driven. Apparently there is a well known design flaw in the Audi C5 A6 vehicles where multiple drains frequently fail. apparently there are 2 very hard to access drains under the battery, under the battery tray, and also the cabin air filter seal to the sidewall is prone to failure. I'm told that there is a "soft" NTSB Audi Recall on this. Please advise.

please see prior form submission re transmission...please confirm receipt of earlier entry.

THE GAS TANK OR COMPONENTS OF THE TANK ARE LEAKING GAS WHEN MORE THAN A SMALL AMOUNT OF GAS IS PUT INTO THE TANK. GAS LEAKS ALL OVER THE GROUND FROM THE TANK AND THE CABIN FILLS WITH GAS FUMES. MY 18 SON HAS BEEN DRIVING THIS CAR AND I WILL NOT ALLOW HIM OR ANYONE ELSE TO DRIVE THE CAR NOW. AFTER READING ONLINE THAT MANY PEOPLE HAVE THIS SAME PROBLEM, I AM SHOCKED THAT THIS IS NOT A RECALL WHEN IT COULD BE POTENTIALLY LIFE THREATENING AND THAT AUDI WANTS TO CHARGE 3K TO LOWER THE TANK AND REPAIR.

TL* THE CONTACT OWNS A 2003 AUDI ALLROAD. THE CONTACT STATED THAT THE AIR BAG WARNING LIGHT WAS ILLUMINATED. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE IT WAS DIAGNOSED WITH NEEDING CLOCK SPRING TO BE REPLACED. THE VEHICLE WAS REPAIRED HOWEVER, THE FAILURE PERSISTED. THE MANUFACTURER WAS NOT INFORMED OF THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 135,000.

TL* THE CONTACT OWNS A 2003 AUDI A6. WHILE DRIVING VARIOUS SPEEDS, THE VEHICLE STALLED WITHOUT WARNING. THE CONTACT STATED THAT THE FAILURE OCCURRED MULTIPLE TIMES. THE VEHICLE WAS TAKEN TO AN UNKNOWN DEALER AND THE CRANKSHAFT SENSOR WAS REPLACED, BUT THE FAILURE PERSISTED. THE VEHICLE WAS NOT TAKEN BACK TO A DEALER FOR DIAGNOSTIC TESTING OR REPAIRS. THE MANUFACTURER WAS CONTACTED, BUT WAS UNABLE TO ASSIST. THE FAILURE MILEAGE WAS 149,000.

TL* TAKATA RECALL. THE CONTACT OWNS A 2003 AUDI A6. THE CONTACT STATED WHILE DRIVING AT VARIOUS SPEEDS ON THE HIGHWAY, THE VEHICLE STALLED WITHOUT WARNING. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. A DEALER WAS NOT CONTACTED. THE MANUFACTURER WAS NOT CONTACTED AND MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 149,000. THE VIN WAS NOT AVAILABLE.

CHECK ENGINE LIGHT ON, VEHICLE WILL NOT PASS EMISSIONS TESTING. AUDI DETERMINED THAT IT WAS DUE TO A FUEL LEAK FROM A CRACK IN THE PASSENGER SIDE REAR ROLLOVER VALVE. VEHICLE HAD BEEN RECALLED IN PAST FOR SIMILAR ISSUE (PERFORMED). TANK HAS 4 ROLLOVER VALVES, ONLY ONE (FRONT DRIVER) INCLUDED IN PRIOR RECALL. INITIAL QUOTED $3,300 TO REPLACE TANK. AUDI OFFERED TO PAY FOR REPLACEMENT TANK WITH THE EXCEPTION OF ~$600 (REPAIR ORDER ATTACHED). REPAIR COMPLETED ON 2/23/2017, CAR PASSES STATE INSPECTION. AS YOU CAN SEE BY THE "STAINING" IN THE ATTACHED PHOTO, THE LEAK WAS SIGNIFICANT DEALER THEN CALLS TO SAY THAT CAR NEEDS TO BE RETURNED TO PERFORM PRIOR RECALL ON THE NEWLY INSTALLED TANK. RECALL TO BE PERFORMED ON ONLY THE ONE ROLLOVER VALVE (DRIVER FRONT) THAT CAN BE ACCESSED WITH OUT REMOVING FUEL TANK. NOT THE VALVE THAT WAS LEAKING AND NECESSITATED THE REPLACEMENT. I REQUESTED THAT AUDI PERFORM RECALL ON ALL 4 ROLLOVER VALVES AS THEY INSTALLED A KNOWINGLY DEFECTIVE PART AND THE RISK OF ANOTHER CRACK/LEAK EXISTS. DEALER SAYS AUDI REFUSES. I HAVE MADE SEVERAL CALLS TO BOTH DEALER AND AUDI WITH NO RESPONSE FROM AUDI BEYOND A CONVERSATION WITH CUSTOMER SERVICE. CHECK ENGINE LIGHT BACK ON 5/08/2017. EMAILED DEALER ON 5/11/2017 (ATTACHED PDF) WITH MY REQUEST (AGAIN), AND HAVE RECEIVED NO CONTACT FROM AUDI. RETURNING CAR TO DEALER FOR RECALL ON THE ONE ROLLOVER VALVE ON 7/12/17. AUDI IS PUTTING THIS CAR BACK ON THE ROAD WITH THE STRONG POTENTIAL OF A FUEL LEAK.

I WAS DRIVING IN LIGHT RAIN AND SAW A SMALL PUDDLE OF WATER AHEAD SO I SLOWED DOWN AND WENT THROUGH IT AT 10MPH, ALL OF THE SUDDEN MY STEERING WHEEL LOCKS UP AND IS STUCK GOING RIGHT, GRINDING NOISE CAME FROM THE FRONT DRIVERS WHEEL. I SOMEHOW MANAGED TO GET THE VEHICAL TO A FIRE STATION AND PARK IT THERE AFTER 30M AND ONLY GOING 20FT THEN ALL OF A SUDDEN WHILE I'M PRESSING THE GAS PEDDLE THE HORRIBLE GRINDING NOISE COMES BACK AND THE CAR GOES NO WHERE IN DRIVE OR REVERSE.

SUNROOF EXPLODED WHILE TRAVELING ON THE FREEWAY.

TL* THE CONTACT OWNS A 2003 AUDI A6. WHILE THE VEHICLE WAS PARKED, THE CONTACT NOTICED A PUDDLE OF FUEL IN THE DRIVEWAY. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE IT WAS DIAGNOSED THAT THE ROLLOVER VALVE HAD A CRACK, CAUSING THE FUEL TANK TO LEAK. THE VEHICLE WAS REPAIRED PER A RECALL, BUT THE FAILURE RECURRED. THE VEHICLE WAS NOT REPAIRED AGAIN. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE RECALL INFORMATION WAS NOT PROVIDED. THE FAILURE MILEAGE WAS APPROXIMATELY 180,000.

THE FUEL TANK HAS DEVELOPED A LEAK ON ITS OWN. I FILLED MY CAR THE THURSDAY SEPTEMBER 3, 2015. ON SEPTEMBER 8, 2015 THE FUEL GAUGE WAS DOWN A QUARTER TANK. I SMELLED GAS OUTSIDE OF THE CAR. MY MECHANIC TELLS ME THE LEAK IS AT A PLASTIC WELDED NUB ON THE RIGHT SIDE OF THE TANK.THIS IS A PLASTIC FUEL TANK. IF I FILL THE TANK ABOVE THE HALFWAY MARK THIS IS WHEN THE TANK LEAKS. THE CAR IS GOING IN FOR SERVICE ON MONDAY FOR A FUEL TANK REPLACEMENT. I HAVE OPENED CASE NUMBER 150699218 WITH AUDI CORPORATE. THEY WANTED ME TO ALLOW THEM TO TOW THE CAR TO A DEALERSHIP AND LET THE DEALER MAKE A DIAGNOSIS. WE WERE DESPERATELY AFRAID THAT THE COST OF THIS WOULD BE EXORBITANT. IT TAKES 10+ HOURS TO GET THE REMOVED AND REINSTALLED. THE TANK IS ABOUT $700.00 WE ARE TRULY AFRAID TO GO TO THE DEALER FOR ANYTHING. WE HAVE AN INDEPENDENT AUDI MECHANIC WE HAVE USED FOR YEARS. AUDI WAS OFFERING TO PAY FOR THE TOW AND THE DIAGNOSIS. WE WERE THINKING AUDI WOULD USE THE EXCUSE OF DISASSEMBLING THE CAR, "FIND THE PROBLEM" AND THEN CHARGE 5 OF THE 10 HOURS TO PUT THE TANK IN. WE DID NOT WANT TO GET STUCK WITH THAT. THIS IS AWHY WE GO TO AN INDEPENDENT MECHANIC WHO IS HIGHLY COMPETENT AND WE TRUST. I WILL KNOW MORE ABOUT THE LEAK ON MONDAY OR TUESDAY . THIS COULD LEAD TO A FIRE.

I HAVE 2003 AUDI A6 QUATTRO 4.2 L. I HAD IN SHOP FOR REAR BRAKES AND MECHANIC NOTED FUEL LEAKING/DRIPPING FROM FRONT DRIVERS SIDE OF PLASTIC FUEL TANK. I DID INTERNET SEARCH AND FOUND RECALL CAMPAIGN 11V267000 AND MANY COMPLAINTS REGARDING SIMILAR LEAKS. I VERIFIED MANUFACTURE DATE 4/3/(2002 OR 2003?) FROM VEHICLE WHICH FALLS IN WINDOW COVERED BY RECALL OF UNITS MANUFACTURED BETWEEN JUNE 19, 2001 THROUGH JUNE 8, 2004. I CONTACTED AUDI AMERICA AND EVENTUALLY SPOKE WITH XXXX AT [XXX]. SHE ASSURED ME THAT MY CAR WAS EITHER NOT SUBJECT TO THE RECALL OR HAD BEEN FIXED. I TOLD HER I WAS THE OWNER OF THE CAR AT THE TIME OF THE RECALL ( MAY 2011) AND MY CAR HAD NOT BEEN FIXED. SHE ROBOTICALLY REPEATED THAT MY CAR HAD EITHER BEEN FIXED OR NOT PART OF THE RECALL. I ASKED HER TO VERIFY THAT IT HAD BEEN FIXED AND SHE SAID THEY HAVE NO RECORDS TO SHOW THAT. SHE SAID I COULD CONTACT THE DEALER THAT ORIGINALLY SOLD THE CAR. I SAID WHY WOULD A DEALER IN WISCONSIN WHO SOLD THE CAR IN 2003 HAVE ANY RECORDS REGARDING A RECALL ISSUED IN 20011 WHEN I OWNED THE CAR? SHE WAS SILENT. I ASKED FOR A LIST OF ALL VINS IN THE RECALL. SHE SAID SHE COULD NOT GIVE ME THAT. SHE AGREED TO SEND ME A "RANGE" OF AFFECTED VIN'S. SHE SAID THEY MIGHT BE ABLE TO HELP ME OUT BUT I NEED TO HAVE AND EVALUATION DONE AT MY EXPENSE AT AN AUDI DEALER TO DETERMINE WHAT IS WRONG. I SAID I KNOW WHAT IS WRING, IT IS LEAKING GAS FROM THE ROLLOVER VALVE CONNECTION ON THE TANK AND REPORTED ALL OVER THE INTERNET IN AUDI FORUMS ETC. I HAVE MADE AN APPOINTMENT WITH AUDI FOR 31 OCTOBER MIN 1 HR LABOR AT $110/HR TO EVALUATE MY LEAK. THIS RECALL NEEDS TO BE ENFORCED AND AUDI NEEDS TO BE HELD ACCOUNTABLE FOR THEIR EVASIVE RESPONSES. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR

FAILED CT EMISSIONS TEST. CHECK ENGINE LIGHT ILLUMINATED. CONFIRMED CODE TO BE P0741. INFORMED BY AUTHORIZED TECHNICIAN THAT THE TORQUE CONVERTER REQUIRES REPLACEMENT. *TR

AT TIMES WHEN DRIVING THE CAR THE ACCELERATION BECOMES SLOW AND IT STALLS WITH A JERK LIKE IT'S GOING TO JUST STOP ALSO, WHEN THE CAR IS PUT IN REVERSE GEAR IT WILL NOT MOVE. I AM STUCK. THE PRND FLASHING ON THE DASHBOARD. I BECOME AFRAID BECAUSE THIS CAN CAUSE SERIOUS ACCIDENTS.

TL* THE CONTACT OWNS A 2003 AUDI A6. THE CONTACT STATED THAT THE SERVICE ENGINE WARNING LIGHT ILLUMINATED. THE CONTACT MENTIONED A LOUD NOISE COMING FROM THE FRONT OF THE VEHICLE INTERMITTENTLY. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER WHO RESET THE CODES BUT THE FAILURE RECURRED. THE VEHICLE WAS TAKEN BACK TO THE AUTHORIZED DEALER WHO INDICATED THAT THE ENGINE MOUNT NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED BUT THE FAILURE RECURRED. IN ADDITION, THE CONTACT STATED WHILE DRIVING 60 MPH, SMOKE STARTED TO EMIT FROM THE ENGINE COMPLARTMENT. THE CONTACT MENTIONED THAT THE FIRE HAD CONSUMED AND BURNED THROUGH THE HOOD AROUND TO THE FRONT DRIVERS SIDE OF THE VEHICLE. THE CONTACT EXITED THE VEHICLE AND THE FIRE DEPARTMENT WAS ABLE TO EXTINGUISH THE FIRE. A POLICE REPORT WAS FILED. NO INJURIES HAD BEEN SUSTAINED. THE CONTACT WAS NOT NOTIFIED OF NHTSA CAMPAIGN ID NUMBER: 11V267000 (FUEL SYSTEM, OTHER), NHTSA CAMPAIGN ID NUMBER: 07V375000 (FUEL SYSTEM, GASOLINE) AND NHTSA CAMPAIGN ID NUMBER: 08V157000 (FUEL SYSTEM, GASOLINE). THE VEHICLE WAS DESTROYED. THE CONTACT WAS AWAITING AN INSURANCE ADJUSTOR TO INSPECT THE VEHICLE. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 87,434. UPDATED 08/25/14*LJ UPDATED 09/5/2014 *JS

THE FIRE STARTED UNDER DASHBOARD AS I WAS DRIVING. I STOPPED THE CAR IN THE MIDDLE OF THE ROAD AND QUICKLY JUMPED OUT THE CAR WHEN SAW A FLAME. THIS WAS THE MOST FREIGHTING EXPERIENCE IN MY LIFE. *TR

ON MAY 3, 2013, I WAS DRIVING ON THE EXPRESSWAY AT APPROXIMATELY 10MPH. SUDDENLY, I BEGAN SMELLING SMOKE. I THOUGHT THE SMOKE WAS COMING FROM NEARBY TRUCKS. HOWEVER, SOON AFTER, SMOKE WAS PROFUSELY COMING THROUGH MY GLOVE COMPARTMENT. I PULLED OVER, TURNED THE CAR OFF, AND EXITED THE CAR. ABOUT 5 MINUTES LATER, THIS VEHICLE ENGULFED IN FLAMES, BEGINNING WITH THE HOOD! THE WIND SHIELD THEN SHATTERED APPROXIMATELY 3 MINUTES LATER. BY THIS TIME, THE FIRE DEPARTMENT ARRIVED AND BATTLED THE FIRE APPROXIMATELY 20 MINUTES. THERE WAS NO PREVIOUS SIGN THAT CAR SERVICE WAS NECESSARY. FURTHERMORE, ACCORDING TO THE DEALER AND DMV, 3 MONTHS AGO, THERE WAS A CLEAN EMISSIONS AT THE TIME OF PURCHASE. *TR

TORQUE CONVERTER DISENGAGES AND POWER / RPM SURGE OCCURS. *TR

CAR BRAKE LIGHTS ARE ON ALL THE TIME AND IT REVES ALL THE TIME. *TR

TL* THE CONTACT OWNS A 2003 AUDI A6 2.7 QUATTRO. THE CONTACT STATED WHILE TRAVELING 20 MPH THE ABS SYSTEM ACTIVATED CAUSING THE VEHICLE TO VEER TO THE LEFT. THE VEHICLE WAS ABLE TO BE DRIVEN TO THE CONTACT'S HOME. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 89,000 AND THE CURRENT MILEAGE WAS 90,500.