2023 Kia Forte

While driving on the freeway at approximately 65 mph, my vehicle suddenly lost normal braking function. The brake pedal felt loose, and I had to press it nearly to the floor for the vehicle to slow down. Even then, stopping took significantly longer than normal. Pumping the brake pedal approximately five times temporarily restored normal braking, but the pedal became loose again afterward. Fortunately, there were no vehicles directly in front of me, allowing me to gradually slow down and exit the freeway. With my hazard lights on, I continued at approximately 5 mph, but the vehicle still did not stop easily when I pressed the brake pedal all the way down. This put my safety and the safety of other motorists at serious risk because I could not reliably stop the vehicle. There were no dashboard warning lights or messages and no unusual noises before or during the incident. i have never had a problem with my brakes before this either. The problem occurred suddenly. My uncle, who is a diesel mechanic, inspected the vehicle and found that the brake lines and fluids appeared to be in good condition. He suspects the brake master cylinder may be the cause, although this has not been confirmed through a formal diagnostic inspection. I have contacted the dealership and am awaiting a response to determine whether they recommend a dealership inspection or an inspection by an independent mechanic. I also contacted Carvana since that is where I got my car from a year ago and included support chat messages. The problem has not yet been formally diagnosed or reproduced by a dealership or independent service center. I am reporting this incident because the sudden loss of reliable braking created a potentially life-threatening situation. The vehicle should be available for inspection upon request, with appropriate towing arrangements.

Front left tire blew out, plastic liner became shredded due to it. Beneath that plastic liner sits the main electrical wiring harness which rubs against the wheel creating sparks leading to total engine fire and failure

The contact owns a 2023 Kia Forte. The contact stated that while driving 25 MPH, the steering wheel became difficult to turn. The contact stated that the steering wheel was loose and was difficult to turn. Due to the failure, the vehicle unexpectedly swayed from left to right. The contact stated that the vehicle felt as if it was floating on water. The vehicle was taken to several dealers but was not diagnosed. The dealer stated that the failure might be associated with a tire failure. The tires were rotated, and an alignment was performed; however, the failure persisted. The vehicle was scheduled for a diagnostic test. The manufacturer was made aware of the failure by telephone and by email, and a case was opened. The contact requested a goodwill assistance to repair the vehicle. The failure mileage was approximately 600.

While car was rolling in reverse, breaks got stiff and driver had to use excessive force to get car to stop. Battery warning came on when pushing hard on the breaks. Then got the car in park, reved the gas to make sure the car was on which it was. Drove it to a parking spot and the car was giving me signal shift to P. No accident occurred. Turned the car off. Car was driven home and all was fine. Vehicle was towed to Kia dealer and they kept it 5 days and could not find any codes in the system and said all was fine and released it back to us today. Told us to let them know if it happens again.

Four times, my 2023 Kia forte has went into limp mode. Three times accelerating onto the freeway, the blindspot/anticollision (BCA) system reset. This put the vehicle in limp mode and it deaccelerated to 3 mph. I had to pull over and restart the car. The other time, I was turning right at an intersection. After the light turned green, the system reset again. I had the AGM battery replaced after the second time, but the BCA system continued to reset and the car went into limp mode. This is dangerous during driving, especially if there is no where to pull over. The car won't go more than three mph.

Unknown. During a basic collision Avoidance maneuver performed by myself on the highway at speed of aprox 60MPH the steering suddenly became non-responsive, resulting in my inability to maintain directional control and cause a collision. The vehicle continued traveling before coming to its final resting position. During this sequence, the driver-side front suspension assembly sustained a catastrophic separation before the impact The steering knuckle was no longer attached to the vehicle, the strut was broken, and the driver-side wheel/tire ultimately ended up underneath the vehicle when the vehicle finally come to a stop . During the event The driver-side axle shaft completely detached and somehow come out of the transaxle housing and was found a significant distance back along the roadway, a great distance back before the initial impact . indicating that it separated before the vehicle reached its final resting position. It is in my strongest opinion the maneuver itself could have potentially been cause of the catastrophic event. And is potentially why I could not maintain complete complete control of vehicle the whole time.

Electrical system failed while operating vehicle on major highway. All lights flashed, system shut off, power steering locked up.

The right front lower control arm has completely broken/fractured during operation. Kia has previously issued safety recalls SC283 (NHTSA 23V649) and SC306 (NHTSA 24V244) for this exact vehicle model year due to improperly manufactured right front lower control arms that can crack and fail. My vehicle was manufactured in March 2023 (03/23), which is just prior to the official April 12, 2023 recall window. Because the component suffered the precise, catastrophic structural failure described in the federal recall campaigns, it is clear that defective parts were used in production earlier than Kia's current recall parameters account for. This is a severe safety hazard that causes an immediate loss of steering control and places occupants at extreme risk of a crash. I am requesting that NHTSA investigate this out-of-window component failure and pressure Kia to expand the recall parameters to protect other owners. The vehicle was in a minor pothole incident six months ago but suffered no suspension failure at that time. This is a fresh, catastrophic fracture just discovered on the right front lower control arm. The fracture is clean, unoxidized, and brand new, proving it is a recent spontaneous material failure matching recalls SC283/SC306, not old accident damage.

The A/C compressor field coil assembly failed on my 2023 Kia Forte. The air conditioning system is completely inoperative. The vehicle is currently [at my residence / at the dealership - specify location] and the component is available for inspection upon request. 1 This is a documented issue. Kia issued Technical Service Bulletin #048 (Revision TSB_CLI048_R1, dated November 18, 2022) for 2019–2023 Kia Forte models, which specifically identifies a defective A/C compressor field coil assembly as the cause of air conditioning failure. The TSB provides diagnostic procedures to isolate an open field coil circuit and states that replacement of the complete compressor assembly is not required when only the field coil is defective. The failed A/C system creates a direct safety hazard because it prevents proper defogging and defrosting of the windshield. 2 On [date of incident, if applicable], while driving [on 101 / in traffic], the windshield began to fog heavily. With the A/C inoperative, I was unable to clear the windows quickly. This significantly reduced visibility and made it difficult to see other vehicles and road conditions. 3 Proper A/C function is essential for safe driving in humid or rainy conditions. Without it, the vehicle's defrost system does not work effectively, which can lead to a crash. 4 NO. The dealership (Van Nuys Kia) and Kia America were contacted but did not schedule an inspection. I am seeking resolution before paying for a repair that should be covered under goodwill for a known defect. 5 The A/C began blowing warm air gradually. No warning lamps or messages appeared on the dashboard. There were no prior symptoms before the system became completely inoperative.

The contact owns a 2023 Kia Forte. The contact stated that while driving at an undisclosed speed, the vehicle made abnormal knocking sounds. No warning light was illuminated. The vehicle later lost motive power while driving with the check engine warning light illuminated. The vehicle was towed to the dealer, and it was determined that the engine needed to be replaced; however, the vehicle was not covered under warranty. The vehicle was not repaired. The contact stated that a week prior to the failure, the vehicle was taken to another dealer to determine the trade-in value, and no failures were found at the time. The manufacturer was made aware of the failure. The failure mileage was approximately 49,000.

I was driving home, on my way while driving I approached a curve on my way around the curve my vehicle continued to accelerate to the right as I was going around the curve. I tried to redirect the vehicle back to the left by trying to turn the steering wheel towards the left but I could not control the direction of the way the vehicle continued on. Still trying to turn the steering wheel back towards the left it kept to the right and ran off the road into a tree. Also once impact occurred i don’t remember if the airbags deployed because my head was laying flat on the steering wheel. Once the emergency services arrived I was accessed and removed from the vehicle and transported to the hospital emergency. There were no warning lights or messages what so ever ahead of the accident. A claim with the insurance was filed and also a complaint with the Kia manufacturer was filed. At this time no one has accessed the damages of the vehicle, State Farm has the vehicle at this time.

I was driving in a road, when a female deer appeared out of the trees and bushes from the right shoulder of the road. I tried not to hit it but but the deer got in my way. I hit the deer and quickly moved over to the right shoulder. The whole front right of the vehicle was destroyed and the airbags did not open. Sheriff arrived and saw the vehicle, the vehicles debri and the deer which had to be put down. He asked for the vehicles registration and did a report of the accident. The Sheriff then called a local tow company who arrived in a couple of minutes and towed the vehicle to their garage/shop.

The contact owns a 2023 Kia Forte. The contact stated that while leaving Walmart and approaching the vehicle, the contact became aware that another driver with a similar vehicle was able to unlock her vehicle with the other driver’s key fob on the passenger’s side of the vehicle. The lights flashed, alerting the contact that the vehicle was unlocked. No warning lights were illuminated prior to the failure. The local dealer was not contacted. The vehicle was not diagnosed or repaired. The manufacturer was not notified of the issue. The failure mileage was unknown. The VIN was not available.

I am reporting a serious and ongoing safety issue involving my 2023 Kia Forte GT. The vehicle has experienced persistent mechanical problems, including a check engine light and multiple diagnostic trouble codes, including P0420 (catalyst system efficiency below threshold – Bank 1), P0300 (random/multiple cylinder misfire), P0304 (cylinder 4 misfire), and P0301 (cylinder 1 misfire). These codes have appeared as stored, pending, and permanent, indicating ongoing and unresolved engine and emissions system issues. In addition to these mechanical problems, the vehicle is emitting strong and concerning chemical fumes into the cabin during operation. These fumes are noticeable while driving and create a hazardous environment for occupants, raising concerns of toxic exposure and making the vehicle unsafe to operate. The vehicle also exhibits drivability issues, including jerking and performance irregularities when accelerating. Despite multiple attempts to have the vehicle diagnosed and repaired under warranty at authorized Kia dealerships, including All Star Kia East and All Star Kia Seigen Lane, the dealerships have refused to properly diagnose or repair the vehicle. I have been informed that my vehicle or account is “flagged in all systems,” and service has been denied on that basis. The refusal to address an emissions-related defect, combined with active misfires and the presence of chemical fumes entering the cabin, presents a serious safety risk. I am requesting that this issue be investigated as a potential safety defect affecting this vehicle.

My son, [XXX] , has opened a complaint/Case #XXX with Kia. His 2023 KIA Forte had been idle for at least 24 hours when the engine compartment caught fire. He became aware of this when the Fire Department knocked on his apartment door around 4:00 PM 12/26/25 and said they were evacuating the building because a car was on fire. He went outside and was shocked, to say the least, that it was his car. The Fire Department had taken off the hood to extinguish the fire. He removed his belongings once the fire was out. He contacted his insurance company but since it was a holiday weekend, he did not get a call back until 12/29/25. He then filed a claim with State Farm Insurance which was required to get his car towed to a Kia repair location. On 1/9/25, [XXX] [XXX] t Castrucci Auto Shop in [XXX] [XXX] he car was totaled. I talked with [XXX] who was [XXX] between the auto shop and State Farm, told me that once the repair exceeded the value of the car, he was instructed by State Farm it was totaled and there was no need to continue. On or around 3/4/26, Kia sent engineers to assess the damaged vehicle. Kia determined it was an engine fire and the cause was undetermined due to the condition of the engine department. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6) INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Backing out of a driveway that had a mud hole. Car got turned and stuck in the mud. We were trying to push it out and then it started smoking under the drivers tires and then we heard a pop. Next thing the undercarriage is on fire and we got away. Withing minutes the whole car was engulfed in flames. UNKNOWN MODERATE ONLY CAUSE WE WERE STUCK AND COULD EXIT THE VEHICLE IN A TIMELY MANNER NO NO

My son was in a car accident in my car January 1 at none of the Air bags went off. Not one there is a police report and I have pictures. Its a 2023 kia forte

Unknown Concerning the front passenger steering component. Carfax showed prior accident with minor damage to the front passenger bumper. I purchased the car not long ago and and was hit in the same exact spot. When I looked up the VIN for more information online I came across the safety issue with some other 2023 forte. I'm concerned that my vehicle could possibly have the same issue though it's not showing up right now under recall.

My low beam headlights seem to burn out at an unusually high rate. Multiple times per year, and this is much higher than any other vehicle that I've owned. I believe there may be some type of electrical issue.

My father was in a fatal vehicle accident in which the car was going very fast and then he crashed into a building. The car then started on fire. The black box was unable to be recovered to check car function. There were no medical findings