2012 Kia Rio

I am filing a safety complaint regarding my 2012 Kia Rio, which currently has approximately 150,000 miles. I first became aware of these problems at approximately 120,000 miles. The vehicle has excessive oil consumption despite being consistently and properly maintained. I have been meticulous about maintenance because the vehicle has a lifetime powertrain warranty, and I have documentation and receipts for required maintenance, including regular oil changes and other scheduled services. On multiple occasions, I have taken the vehicle in for a scheduled oil change and discovered that it had little or no oil remaining. Because of this, I have had to begin having oil added between regularly scheduled oil changes. I do not know the exact amount of oil being consumed because I initially had no reason to monitor or measure oil consumption between oil changes. The vehicle also has a recurring catalytic-converter/check-engine warning that comes on, goes off, and later returns. It has experienced noticeable loss of power and has developed a clicking or knocking sound from the engine. When the vehicle is sitting or idling, it can also indicate that it is running hot even though it does not appear to actually be overheating. These problems have continued despite regular, documented maintenance. I am concerned about the safety implications of a vehicle consuming enough oil to have little or no oil remaining before its next scheduled oil change, particularly when there may be no consistent warning to alert the driver that the oil level is dangerously low. I am also concerned about the recurring catalytic-converter warning, loss of engine power, abnormal engine noise, and the possibility of engine or catalytic-converter failure while the vehicle is being driven. I understand that other Kia vehicles have been subject to recalls and investigations involving engine-related defects. I am asking NHTSA to review complaints involving the 2012 Kia Rio and investigate whether exces

I went to honk my horn as someone was backing up and didn’t see me as we were on an incline . This vehicle sits low and they were in a jeep. Due to the failure of my horn, I was unable to give a warning and they hit my car. No airbag was deployed and my seatbelt/airbag light is on. No injuries reported thankfully. I was told these things were related and repairs needed which is going to be extensive. The airbag may not deploy and horn does not work. I consider this a definite safety issue.

The airbag warning light and the ABS warning light turned on simultaneously while driving. This is a severe safety hazard as both critical, life-saving safety features are currently compromised. I have already contacted Kia Customer Care regarding this issue, but I am filing this official complaint with the NHTSA to ensure a proper safety investigation is documented for this vehicle.

The airbag warning light illuminated on the dashboard and has stayed on permanently. This indicates a malfunction in the supplemental restraint system (SRS). Because the warning light is active, there is a severe safety risk that the airbags may not deploy correctly or at all in the event of a crash, putting the driver and passengers at risk of serious injury. The vehicle is available for inspection upon request

Waiting to get air in my tire. Car was turned off and the car started fire under the hood.

I brought my Kia in for a recall, and they determined the part was discontinued thus making my vehicle inoperable. When I brought my vehicle in, it was driveable-now I have been without my vehicle for over a month.

I went to the Kia dealership in Laredo Texas and was told that they cannot fix the fault, that my vehicle has had an aftermarket parts, that they are not going to fix the HECU. That they don't fix vehicle with aftermarket parts.

The GDI 1.6L engines are manufactured with a flaw that affects piston rings and makes oil consumption go up which in turn can make the engine run dry and damage the engine, which if you're in a bad location could be dangerous. My car has been dealing with the issue and I searched yet found no recalls for the engine. 2. It can put me and others at risk, if my car breaks and I'm driving in a snowy or hot area, or breaks when driving up hill or down hill. 3. Look all over the internet GDI 1.6 Oil consumption issue. 4. Yes, repair shop. 5. Plenty of times barely drove 200 miles and I get the red lamp for no oil/low oil level.

Our granddaughter bought this car from a private seller. My son is a mechanic and when he inspected the undercarriage he found a small leak in the seam of the gas tank. The local KIA dealer said it is not covered. This, to me, is a safety and emissions issue. Please assist. The car is available at any time for inspection. Thank you

The contact owns a 2012 Kia Rio. The contact received notification of NHTSA Campaign Number: 23V652000 (Service Brakes, Hydraulic) however, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The dealer was made aware of the issue and confirmed that parts were not yet available. The manufacturer was made aware of the issue and confirmed that parts were not yet available. The contact had not experienced a failure. VIN tool confirms parts not available.

The contact's sister owns a 2012 Kia Rio. The contact received notification of NHTSA Campaign Number: 23V652000 (Service Brakes, Hydraulic). The contact stated that when her sister started the vehicle, the check engine warning light illuminated. The vehicle was not diagnosed or repaired. The manufacturer was made aware of the failure. The failure mileage was unknown.

The contact owns a 2012 Kia Rio. The contact received notification of NHTSA Campaign Number: 23V652000 (Service Brakes, Hydraulic) however, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The dealer was made aware of the issue. The manufacturer was made aware of the issue and confirmed that parts were not yet available. The contact had not experienced a failure. VIN tool confirms parts not available.

Car started running oddly pulled over went to restart and Fire came up an engine compartment

The contact owns a 2012 Kia Rio. The contact stated that after the niece had park and exited the vehicle smoke and flames were present coming from under the hood of the vehicle. The fire department was called to scene to extinguish the flames. During the incident the vehicle was destroyed and towed away. The cause of the failure was not determined. The contact indicated that prior to the incident the vehicle was experiencing excessive oil consumption but no assistance was offered from local dealer. The manufacturer was not notified of the failure. The failure mileage was 108,000.

Check engine light comes on. I pull the code of p050a. I looked that up and there is a Techincal Service Bulletin, from Kia on this problem of Cold start idle air control system performance. Kia only put out a recall on the Kia Soul and not the Kia Rio. They have the exact same engine and computer with the 1.6L. The bulletin list both vehicle but the recall is only for the 1 vehicle. I was told by Kia dealer sorry to fix this I would have to pay to reprogram the computer. Kia originally was replacing the throttle body on the engine than decided because of cost, to reprogram the computer.

The contact owns a 2012 Kia Rio. The contact stated that while driving at an unknown speed, the RPMs was rising to the red line immediately. The vehicle was towed to the residence. The vehicle was taken to the dealer where it was diagnosed that there was transmission maintenance needed on the vehicle. The vehicle was repaired however, the failure persisted. The vehicle was taken to an independent mechanic who was unable to duplicate the failure. The vehicle was not repaired, and the failure continued. The vehicle was towed back to the dealer and the towing technician noticed that the accelerator pedal was stuck. The vehicle was not repaired. The manufacturer was notified of the failure. The approximate failure mileage was 64,000.

Will not start early morning, use about 3 quart oil a week, before warranty ran out Kia dealer check out and said to drive it another 900 miles, which made no sense, and bring back in Then they said it was out of warranty, what a scam Kia dealership is.they had overfill oil level 3 times before this problem

2012 KIA RIO, NOT CURRENTLY SUBJECT TO ANY RECALL, AND HAVING BEEN MAINTAINED CORRECTLY, IS EXPERIENCING DANGEROUS LEVELS OF OIL CONSUMPTION. CURRENT MILAGE 108,000. TWO WEEKS AGO I SENT THE ATTACHED LETTER VIA CASE TO KIA CONSUMER CUSTOMER AFFAIRS SEEKING SAFETY ADVICE FROM THE COMPANY RELATING TO THE ISSUE. KIA NEVER RESPONDED, OPTING TO CLOSE THE CASE WITHOUT A WORD REGARDING THE ISSUE. OIL CONSUMPTION IS VERY HIGH, AND EFFECTING ENGINE PERFORMANCE. I ASSUME THE ONLY RECOURSE IS TO HAVE THE ENGINE TAKEN APART AND EXAMINED, A COSTLY REVIEW, HOWEVER DUE TO LACK OF RESPONSE FROM KIA I HAVEN'T YET; I WAS HOPING THEY COULD COORDINATE THROUGH EITHER A DEALER OR 3RD PARTY INVESTIGATOR. CURRENTLY THE CAR IS NOT BEING USED, AS THIS ANOMALOUS ISSUE IS A CONCERN FOR SAFETY WHEN DRIVING. CONSIDERING THE RECENT RECALL, AS WELL AS HOW THE SYMPTOMS ALIGN WITH PREVIOUSLY RECORDED ISSUES TO SIMILAR ENGINES, I WISHED TO CREATE THIS REPORT, IF ONLY TO ADD MY CASE TO NHTSA'S ACCOUNTS. THANK YOU FOR YOUR TIME JOSEPH ELLIOTT

I RECENTLY PURCHASED MY VEHICLE AND IMMEDIATELY NOTICED WHAT SEEMS TO BE OIL COMING FROM THE ENGINE, POOLING ON TOP OF THE BLOCK BUT ALSO LEAKING ONTO THE GROUND AFTER BEING PARKED FOR AN HOUR OR SO. THE WALLS AROUND THE ENGINE, MAINLY ON THE LEFT SIDE OR PASSENGER SIDE WERE SATURATED WITH PRESUMABLY THE SAME FLUID. UNDER THE CAR IS ALSO SATURATED FROM WHAT I AM GUESSING TO BE A LEAK, PERHAPS THE SAME LEAK FROM ATOP THE ENGINE BLOCK. I'VE HAD THE CAR REPAIRED AND PAID FOR A SYSTEM FAULT DIAGNOSTIC, AND IN BOTH CASES HAVEN'T RECEIVED ANY HELPFUL INFO AS TO WHAT IT IS, THE CAUSE OR WHERE THE LEAK IS COMING FROM, OR HOW TO TREAT IT. I VERY RECENTLY HAD THE OIL CHANGED AND THE INVOICE SHOWED A COMMENT STATING THAT MY CAR APPEARS TO BE LEAKING OIL. THERE WAS NO FURTHER COMMENTARY. I FEAR THAT MY KIA RIO MAY BE DANGEROUS TO DRIVE FOR REASONS SUCH AS A FIRE HAZARD OR BREAKDOWN FROM OVERHEATING POSSIBLY RESULTING IN LEAVING ME ON THE SIDE OF A HIGHWAY, STRANDED. ALSO THE A/C AND HEATER DO NOT OPERATE AS THEY SHOULD. THE PANEL CONTROLS ARE OUT OF WHACK AND NEITHER A/C OR HEAT PERFORM IN SYNC WITH THE COMMANDS. A MECHANIC HAS SAID THIS APPEARS TO BE DUE TO ELECTRICAL ISSUES, POSSIBLY WITH THE MAIN COMPUTER, THOUGH THE SYSTEMS FAULT DIAGNOSTICS WAS PERFORMED AFTER THE MECHANIC INFORMED ME OF THIS, AND SEEING THAT I WAS CHARGED FOR THAT SERVICE I CAN ONLY ASSUME THAT THE MAIN COMPUTER IS DOING WHAT IT IS MEANT TO DO, RELAYING THE INFO TO THE TECH'S COMPUTER. I JUST DON'T KNOW IF I HAVE A GOOD CAR THAT NEEDS A LOT OF WORK OR IF I'M DRIVING A DEATHTRAP. NO RECALLS FOR THIS VEHICLE BUT I SEE A LOT OF KIA'S VEHICLES BEING RECALLED. AND I BELIEVE THEY NO LONGER MAKE THE KIA RIO. JUST AT A LOSS AS TO WHAT IS HAPPENING AND WHAT TO DO ABOUT IT. TIMES ARE TOUGH FINANCIALLY OR I WOULD DEFINITELY HAVE MORE PROPER DETAILED INFO TO GIVE, THAT OR HAVE A GOOD RUNNING CAR...

I WAS DRIVING AND CHECH ENGINE LIGHT CAME ON . I HAD IT TESTED AND IT WAS THE KNOCK SENOR. I LOOKED IT UP AND THEIR WAS A RECALL I PURCHASED THE CAR 9/02/2019