2003 Mini Cooper

The contact owns a 2003 Mini Cooper. The contact stated that while operating the vehicle, the steering wheel was difficult to turn in either direction. The contact stated that the steering wheel malfunctioned, making the steering wheel easy to turn, causing severe oversteer while making a turn in either direction. The contact stated that the failure was due to a faulty power steering pump, and installed as part of the NHTSA Campaign Number: 15V660000 (STEERING). The vehicle was not repaired. The contact stated that after turning off the vehicle, the power steering pump remained running, causing the battery to drain. The cause of the failure was not yet determined, and the vehicle was not yet repaired. The manufacturer and local dealer were notified of the failure but no assistance was offered. The failure mileage was 230,000.

68k miles on a 2003 mini cooper s and the power steering pump is whining. I feel as if this may be really early for it to be needing to be replaced.

The contact owns a 2003 Mini Cooper. The contact received notification of NHTSA Campaign Number: 15V660000 (Steering); however, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The contact stated that while driving at an undisclosed speed, the steering wheel was firm, and the vehicle was difficult to maneuver. No warning lights were illuminated. The dealer was made aware of the failure but failed to confirm if the parts were available for the repair. The vehicle was not repaired. The manufacturer was made aware of the failure and advised the contact to call the service center directly. The failure mileage was unavailable. Parts distribution disconnect.

No air or blower or heat to defog windshield. Water in driver-side foot well. Power steering intermittent fault. Engine continues running and panel gauge lights remain on with ignition off and key removed.

The contact owns a 2003 Mini Cooper S equipped with Falken Tires, Tire Line: Sincera SN250 A/S, Tire Size: 235/45R17, DOT Number: FMHR3120. The contact stated that while washing the vehicle, he noticed that a bubble had developed on the front driver’s side tire. The contact was concerned for his safety while driving the vehicle. The contact stated that he rotated the tire to the rear driver’s side but was concerned and uncertain if the bubble might cause a risk to his safety while driving. The vehicle had not yet been diagnosed. The vehicle was not repaired. Neither the dealer nor the manufacturer was notified of the failure. The failure mileage was approximately 101,000.

i Purchased the car in Dover Pa . INspection sticker had same milage as on car so i shoulda knew he slapped a sticker on . drove 150 miles dash lit ip like chrismas tree. 1st thing left window wont work , then left lock wont work had to lock from passenfger dide. then door wont open at all . have to get ou t passenger door . know that wont open have to put down passenger window pull handel to get out . car is possessed light work whren they want does all kinda crazt stuff . batter has problems . charge and still cant start it . and hatch locks so i cant get to battery. power steering leaking going bad . timing belt making noise . no power on hills .cracking noise in right front pulls to right had . hazard to me ive been locked inside three times could get out of car i coulda sat in heat and died or cold and froze . cant get out of car when it ts electric doors dont work . car sucks . this has been gradual thing these events from feb to may . now i just hate the car

My 2003 Mini Cooper was affected by the 2015 electrohydraulic steering assistance recall. Mini did the repair at 79, 322 miles in 2016. In November 2021, at 98, 000 miles, the car began having intermittent power steering loss. The power steering might disappear for under a minute, or it might return for mere seconds. There is no warning when the power steering goes out, so you have to assume that it is not going to respond with the electrohydraulic steering assistance feature operating. As of today, it has been completely offline for 3 days (although it did come back on for about 5 seconds yesterday). Without this feature operating properly, the car can be extremely difficult to steer.

While driving on I-81 to NY state, I experienced serious tire vibration followed by tire loss of air. All tires were checked for proper tire inflation before trip. The service center in which I ended up in said that the tire belts had separated and caused the rapid tire deflation.

While driving on I-81 to NY state, I experienced serious tire vibration followed by tire loss of air. All tires were checked for proper tire inflation before trip. After pulling off to the side of the road, I witnessed a large hole with metal fiber sticking through the tire tread. I believe the tread separation was the cause.

The contact owns a 2003 Mini Cooper. The contact stated that while driving approximately 35 mph and making a right turn, the power steering malfunctioned and the steering wheel suddenly became difficult to turn in either direction. The vehicle was taken to the local dealer who diagnosed that the power steering pump and fan needed to be replaced and the intake and return power steering lines also were faulty and needed to be replaced. The manufacturer was notified of the failure. The contact was informed that the vehicle was not included in the NHTSA campaign number: 15V660000 (Steering). The contact indicated that the vehicle had experienced the same failure listed in the recall. The failure mileage was approximately 134,000.

I WAS STARTING MY VEHICLE AND IT MADE A BAD KNOCKING NOISE THEN IT WAS LIKE CRUNCHING NOISE SO I STOPPED TURN IT OFF AND WAITED FOR A WHILE WENT BACK TO THE CAR STILL MAKING A STRANGE NOISE BUT ONCE I PUT IT IN THE DRIVE IT STOPPED MAKING NOISE DROVE DOWN THE ROAD A BIT AND TALKING ABOUT APPARENTLY SLIPS OFF OF THE CAR SO IT JUST PULLS OVER INSIDE ALL THE ALL THE WEARING LIGHTS CAME ON SO PULLED OVER APPARENTLY THIS HAPPENS QUITE OFTEN BUT THE HARMONIC BALANCER SEPARATED AND WITH SPINNING AGAINST ITSELF AND KNOCKED THE PIECES OFF OF IT AND THROUGH THE SERPENTINE BELT SO THAT NEEDS TO REPLACE NOW THAT SHOULD NOT HAPPEN IT'S ONE PIECE IS THIS ONE PIECE THIS NEEDS TO BE RECALLED FOR THESE WHATEVER CARS HAD THESE HARMONIC BALANCERS IS DANGEROUS AND IT COULD BLOW YOUR CAR UP THANK YOU

TL* THE CONTACT OWNS A 2003 MINI COOPER S. THE CONTACT STATED THAT ON THREE OCCASIONS, THE MAT OCCUPANCY SENSOR ON THE FRONT PASSENGER'S SEAT WAS REPLACED DUE TO THE WARNING LIGHT BEING ILLUMINATED. THE VEHICLE WAS TAKEN TO MINI OF BIRMINGHAM LOCATED AT 2001 TOM WILLIAMS WAY, BIRMINGHAM, AL 35210, 205-267-4505. THE CONTACT WAS INFORMED THAT THE MAT SENSOR NEEDED TO BE REPLACED AT A COST OF $1,200. THE CONTACT WAS ALSO INFORMED THAT THE PART MAY ALSO BE AVAILABLE AT THE LOCAL JUNKYARD. THE MAT SENSOR WAS REPLACED HOWEVER, THE FAILURE RECURRED. THE CONTACT WAS INFORMED THAT THE SEAT SHOULD BE REPLACED WHICH WAS STILL PENDING. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 79,000.

IN MOTION.. THE POWER STEERING WHEEL FEELS TO HARD TO TURN OPERATE;I CHECK THE VIN# NUMBER AND APPEAR (1) RECALL FOR POWER STEERING INCOMPLETE;WE CALL AT BMW OF DALLAS AND THEY SETUP AN APOINMENT ON JANUARY,15,2020...WHEN I SHOW UP...THEY SAY MY CAR DON'T HAVE ANY RECALL;AND I SHOW IM THE OFFICIAL RECALL WITH MY VIN#...BMW RECALL & NHTSA RECALL AND THEY SAY THE CAR WARRANTY IS EXPIRED,I SAID I JUST NEED FIX THE RECALL ON MY CAR AND THEY WANNA CHARGE ME $180 DLLS JUST TO GET THE VEHICLE INSPECTED,IF THE CAR GOT SOMETHING WRONG THEY CHARGE ME THE COST...I DONT ACCEPT...MY CAR GOT THE RECALL AND THEY MAKE ME DRIVE 120 MILES WHIT THE CAR FOR NOTHING

WE KNOW OF TWICE THAT OUR CAR'S POWER STEERING PUMP FAILED WHILE IN MOTION. AFTER BMW WAS FINALLY FORCED INTO A RECALL FOR THE POWER STEERING PUMP FAILURE AND WE RECEIVED A NOTIFICATION, WE TOOK OUR CAR TO CENTURY BMW IN GREENVILLE, SC. THE SERVICE DEPARTMENT CHECKED OUR WORK REGARDING REPLACEMENT PUMP, FAN, ETC. AND DEEMED IT 100% SATISFACTORY. WE SUBMITTED THE PAPERWORK AND INVOICE FOR THE REPAIR AND WAITED (REQUESTED . AFTER 16 WEEKS AND NO REIMBURSEMENT OR NOTIFICATION, WE CALLED AND WAS INFORMED BY THE SERVICE DEPARTMENT MANAGER THAT BMW WOULDN'T PAY US ANYTHING BECAUSE WE DIDN'T USE OEM PARTS. WHY WOULD WE KEEP REPLACING THE PUMP (THIS WAS THE 3RD PUMP THAT WE KNOW OF) WITH A DEFECTIVE ONE (BY ZF) THAT KEPT QUITTING? WE REPLACED IT WITH DORMAN (WELL-KNOWN MANUFACTURER OF QUALITY PARTS) WHICH HAD A LIFE-TIME WARRANTY (LIFE-TIME!) AND WAS MUCH CHEAPER. THE SD MANAGER EVEN SAID THAT SINCE HE'D SEEN SO MANY REPAIRS USING THAT BRAND OF POWER STEERING PUMP HE HAD RESEARCHED THEM AND FOUND NOTHING WRONG WITH THEM. BUT BMW DECIDED THEY WOULDN'T PAY FOR THIS. THERE WAS NOTHING IN THE RECALL LETTER THAT SAID OEM HAD TO BE USED OR THEY WOULDN'T REIMBURSE FOR REPAIRS. I BELIEVE BMW SAW SO MANY DORMAN PUMPS USED THEY KNEW THEY COULD SAVE A LOT OF MONEY BY REFUSING TO PAY. WE FILED A COMPLAINT WITH THE SC DEPT. OF CONSUMER AFFAIRS BUT BMW WOULDN'T ANSWER THEM SO THEY JUST DROPPED IT, LETTING BMW GET BY WITH THIS. WE WERE ONLY REQUESTING $721.04 WHICH IS LESS THAN HALF OF WHAT A REPAIR SHOP WOULD HAVE CHARGED. CAN YOU DO ANYTHING ABOUT THIS? WE FILED THE COMPLAINT WITH SC CONSUMER AFFAIRS IN DECEMBER OF 2017, TOOK THE CAR TO BMW IN MAY OF 2017 SO THIS HAS BEEN GOING ON FOR A WHILE. HAVE OTHER OWNERS HAD THIS PROBLEM? HAS A LAWSUIT BEEN STARTED AGAINST BMW?

TL* THE CONTACT OWNS A 2003 MINI COOPER. WHILE DRIVING 30 MPH, THE POWER STEERING COMPLETELY FAILED WITHOUT WARNING. THE CONTACT WAS ABLE TO REGAIN CONTROL OF THE VEHICLE; HOWEVER, THE STEERING WAS ROUGH AND STIFF. THE CONTACT PERFORMED HIS OWN INSPECTION ON THE VEHICLE AND NOTICED THAT THE POWER STEERING PUMP WAS LEAKING. THE CONTACT SPOKE WITH AN INDEPENDENT MECHANIC AND WAS INFORMED THAT THE VEHICLE MAY BE INCLUDED IN AN UNKNOWN RECALL. THE MANUFACTURER WAS INFORMED OF THE FAILURE AND STATED THAT THE VEHICLE WAS INCLUDED IN NHTSA CAMPAIGN NUMBER: 15V660000 (STEERING). THE CONTACT TOOK THE VEHICLE TO MINI OF THE WOODLANDS (16675 I-45, CONROE, TX 77385, 936-344-1258) AND WAS INFORMED THAT THE VEHICLE COULD NOT BE REPAIRED BECAUSE THE STEERING PUMP WAS NOT THE ORIGINAL MINI COOPER STEERING PUMP. THE DEALER OFFERED NO FURTHER ASSISTANCE. THE PUMP HAD NOT BEEN REPLACED. THE FAILURE MILEAGE WAS 83,000.

POWER STEERING PUMP FAILED WHILE DRIVING

BOUGHT THIS CAR FOR 16 YR OLD DAUGHTER. STEERING WAS CUTTING OUT WHILE DRIVING TOOK CAR TO MINI OF DALLAS RECALL WAS DONE ON HARNESS, PUMP, COOLING FAN. NEXT WEEK NO STEERING AGAIN WHILE DRIVING TOOK CAR BACK. MINI STATED DRIVE BELT BROKE AND WAS REPAIRED FOR 260.00. 3 DAYS LATER WAS CALLED AT A 11:30 AT NIGHT MY DAUGHTER STATING THE STEERING HAD CUT OUT AGAIN. I DON'T WANT MY DAUGHTER IN THIS CAR OR ANYONE ELSE FOR THAT MATTER WHAT SHOULD I DO WITH THIS CAR.

THE WARNING FOR TH EPASSENGER AIRBAG COMES ON, THOUGH APPARENTLY NOTHING IS WROMG WITH IT. IT SEEMS TO BE A COMMMON PROBLEM THAT MINI IS AWARE OFF, PUTS PEOPLE IN DANGER, BUT DOESNT DO ANYTHING TO FIX THE HARNESS UNDERNEATH THE PASSENGER SEAT, WHICH THEY QUOTE AT 1200 TO 1400 TO REPAIR THEIR ILL DESIGN AND FINAL PRODUCT

OCCASIONALLY THE STEERING OVER MY MINI COOPER S IS BECOMING VERY HARD. IT SEEMS LIKE THE POWER STEERING IS FAILING. THE CAR THEN CAN ONLY BE STEERED WITH A LOT OF DIFFICULTY. I CAN NO LONGER RISK TO HAVE MY DAUGHTER OR WIFE DRIVE THIS CAR. I CHECKED THE STEERING FLUID AND IT IS AT OPTIMAL LEVELS. IT USUALLY HAPPENS AT LOWER SPEED, BUT I HAVE NOT DRIVEN IT ON THE FREEWAY SINCE THIS ISSUE STARTED TO APPEAR.

POWER STEERING FAILURE - INTERMITTENT AND DURING MOTION, MINI DEALERSHIP PROVIDED RECORDS THAT THE CLAIM WAS CLEARED WITH # AND MILEAGE, BUT THIS IS FALSE INFORMATION IF STILL COVERED BY NHTSA # 15V660000. ORIGINAL RECALL # THAT WAS ENTERED IN THE "REPAIR HISTORY" FROM MINI THAT NEVER OCCURRED IS M320215. THANK YOU