2003 Pontiac Sunfire

EVERY TIME I LET MY CAR SIT FOR 2 HOURS OR MORE, I START IT UP AND THE BELT ON THE TENSIONER SQUEAK FOR 15 SECONDS. ALSO THE BATTERY LIGHT COMES ON AND THE RIM FLUCTUATE BETWEEN 1,000 AND 2,000. WHEN I DRIVE IT THE BATTERY LIGHT WILL CONTINUE TO STAY ON BUT EVERY TIME THE AIR BAG LIGHT TURNS ON AND I'M ACCELERATING THE ENGINE WILL NOT SHIFT, THE RPMS WILL REV UP TO RED LINE IF PUSHED THAT FAR, EVENTUALLY THE LIGHT FOR AIRBAG AND BATTERY WILL SHUT OFF AND IT WILL SHIFT. SOMETIMES WHEN I HIT THE GAS PEDAL WHILE THIS IS DOING THIS AT NIGHT, MY DASHBOARD AS WELL AS RADIO LIGHTS WILL SHUT OFF UNTIL RPMS GO DOWN TO 2,000. *TR

TL* THE CONTACT OWNS A 2003 PONTIAC SUNFIRE. WHILE DRIVING AT AN UNKNOWN SPEED, THE CONTACT HEARD A RATTLING NOISE FROM THE ENGINE COMPARTMENT. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHO STATED THAT THE TIMING CHAIN SEPARATED AND CAUSED THE TENSIONER AND VALVE TO FAIL. THE TIMING CHAIN VALVE AND TENSIONER WERE REPLACED, BUT THE FAILURE RECURRED. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 98,000.

I WAS DRIVING HOME FROM VERNON DOWN'S CASINO AND WAS MAKING A RIGHT AND WAS ABOUT TO SWITCH INTO THIRD GEAR THE RPM'S WHERE 3000 AND THE ENGINE JUST DIED ........ MAUGERI''S AUTO ON ALBANY AND BLEEKER ST. TOWED MY CAR TO HIS SHOP FIXED THE STEERING COLUMN AS A RESULT OF THE ENGINE DIEING THE WINDOW'S WONT ROLL UP AND THE INTERIOR JUST GOT SOAKED IN WET IN THE RAIN AFTER ON THE DATE OF 7/714 PAID ALMOST A GRAND FOR TOWING AND STEERING COLUMN IN THE VEHICLE . I AM A RECIPIENT OF THE TRAUMATIC BRAIN INJURY PROGRAM AND USE THE VEHICLE TO AND FROM MY STRUCTURED DAY AS WELL AS MY NEUROLOGIST AS WELL AS MY HEMATOLOGIST WHO'S OFFICES ARE 57 MILES AWAY FROM MY HOUSE IT IS GOING TO BE VERY UNCOMFORTABLE TO DRIVE TO MY DR. APPT. IN THE MORNING... I AM ON SOCIAL SECURITY DISABILITY AND A FIXED INCOME RECEIVER LESS THEN 700 DOLLARS A MONTH... *TR UPDATED 2/6/2015 *JS

BOUGHT A 2003 PONTIAC SUNFIRE FROM A DEALERSHIP 5 MONTHS AGO. I TOLD THE OWNER/SALESMAN I WANTED A SAFE 1ST CAR FOR MY KID. MY KID AND SOME FRIENDS WERE DRIVING,IT WAS RAINING AND THE BACK TIRES STARTED TO SLIDE,MY KID REGAINED CONTROL OF THE CAR BRIEFLY AND SAID AFTER A FEW MINUTES THE STEERING LOCKED UP AND THEY ENDED UP IN A SPIN. THE CAR HIT AN OBJECT ON THE PASSENGER SIDE,SPUN AROUND AND HIT ANOTHER ON THE DRIVERS SIDE,THEN BOUNCED OFF THAT AND LANDED ACROSS A DEEP DITCH WHERE IT WAS HIT AGAIN IN THE REAR WHEN STOPPING. NO STEERING. NO BRAKES. THE ENGINE WAS STILL GOING EVEN THOUGH THE FRONT END OF THE CAR WAS WEDGED INTO THE EDGE OF THE PAVEMENT AND THE EMBANKMENT OF THE DITCH. BY THE GRACE OF GOD NO ONE WAS PHYSICALLY INJURED. WE HAD THE CAR TOWED TO OUR HOME. MY KID SAID THAT BEFORE THE ACCIDENT THE STEERING WHEEL FELT " WIGGLEY". WE LOOKED AT THAT AREA 1ST. THE STEERING COLUMN WAS LOOSE. THE PIVOT PIN FOR THE COLUMN WAS GONE. I SAW THERE WAS A RECALL IN OCTOBER OF 2008. I CALLED GM TO REQUEST THE RECORDS TO FIND OUT IF THE REPAIR WAS EVER DONE. THE GM REP REFUSED TO GIVE ME THE INFORMATION IN THE DATA BASE. HE SAID I COULD GET IT FROM A "CERTIFIED" GM DEALER! HE ALSO SAID THERE WAS NO RECALL ON THE STEERING, BUT THERE WAS OTHERS. I ASKED WHAT THEY WERE AND AGAIN HE SAID HE COULDN'T GIVE ME THAT INFORMATION. I ALSO OWN A PONTIAC G5 THAT'S BEEN WAITING FOR PARTS ON THE IGNITION RECALL. I HAVE BEEN ON A LIST AT MY DEALERSHIP. I AM MAD AS HELL! ALL MY KID HAS NOW IS THE COMFORT OF KNOWING THE FRIENDS WEREN'T HURT OR KILLED. SOME 1ST CAR, HUH? SPENT 5000.00 OF 401K MONEY FOR A DEATH TRAP THAT GM REFUSES TO GIVE ME THE DATABASE HISTORY ON. CAN'T DRIVE IT, CAN'T SELL IT, AND WITH NO HISTORY, CAN'T FIX IT. LIABILITY AND COMP, THAT'S ALL WE COULD AFFORD, INSURANCE IS TOO EXPENSIVE FOR YOUNG DRIVERS. THERE IS NO MIDDLE CLASS AND THIS KIND OF THING IS WHY. *JS

TL* THE CONTACT OWNS A 2003 PONTIAC SUNFIRE. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 5 MPH, THE VEHICLE STALLED WITHOUT WARNING. THE VEHICLE WAS TOWED TO A PRIVATE MECHANIC WHERE IT WAS DIAGNOSED THAT THE FUEL FILTER NEEDED TO BE REPLACED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE VEHICLE WAS REPAIRED BUT DID NOT RECTIFY THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 120,000 AND THE CURRENT MILEAGE WAS 130,000. *TR

I WAS DRIVING ON THE HIGHWAY AROUND 5:00PM, PERFECT ROAD CONDITIONS. I STARTED CHOKING & SWERVED INTO ANOTHER LANE, OTHER DRIVER BLASTED HIS HORN & SCARED ME. I OVER COMPENSATED & LOST CONTROL OF MY CAR & ENDED UP HITTING THE MEDIAN. MY AIRBAGS DEPLOYED, THE PASSENGER SIDE WAS FINE, BUT THE DRIVERS SIDE DIDN'T DEPLOY CORRECTLY. THE AIR BAG CAME OUT OF THE SIDE & NOT DIRECTLY IN FRONT OF ME. THE AIRBAG BLEW MY REAR VIEW MIRROR OFF OF THE WIND SHIELD & ENDED UP BREAKING MY RIGHT HAND IN MULTIPLE PLACES. MY SEAT BELT ALSO CAME UNDONE. I AM ONLY 5 FEET TALL & IF THE AIRBAG HAD GONE OFF LIKE IT SHOULD'VE, I KNOW I WOULD HAVE HAD NUMEROUS INJURIES TO MY FACE & CHEST. THE REASON I AM MAKING A COMPLAINT IS DUE TO THE FACT THAT HAD I HIT THIS WALL HEAD ON, I MOST LIKELY WOULD'VE BEEN KILLED. AT THIS TIME I DO NOT KNOW THE VIN OR CORRECT MILES, MY CAR AS TOTALED & IT'S STILL WITH THE TOW COMPANY. I BELIEVE THIS, ALONG WITH THE SEAT BELT UNLOCKING ON IT'S OWN AFTER A SERIOUS ACCIDENT, TO BE TREMENDOUSLY DANGEROUS. *TR

I HAVE BEEN DRIVING A 2003 PONTIAC SUNFIRE SINCE 2008. MY FAMILY BOUGHT IT BRAND NEW WITH ONLY 27 MILES ON IT. EVERY WINTER WHEN IT IS REALLY COLD, THE TEMPERATURE GAUGE WOULD NOT ALWAYS RESET ITSELF AFTER THE CAR WAS TURNED OFF. THIS WOULD RESULT IN THE FUEL GAUGE GOING ALL OVER THE PLACE BUT EVENTUALLY IT WOULD RESET ITSELF. HOWEVER, IN SEPTEMBER OF 2012, ALL OF MY GAUGES ON MY DASH WENT ALL OVER THE PLACE. MY TEMPERATURE GAUGE HAS SINCE SPUN COMPLETELY AROUND AND IS STUCK ON THE PLASTIC FROM THE DASH. ALSO, MY SPEEDOMETER IS NOW NOT RESETTING ITSELF. IT HAS SAID THAT I WAS AT 40 MPH WHILE SITTING AT A STOP LIGHT. I DO KNOW THAT THE TEMPERATURE HAS DROPPED WHICH COULD BE EFFECTING THINGS BUT THIS ISSUE IS JUST PLAIN ANNOYING ANYMORE. I CAN DEAL WITH THE FUEL GAUGE NOT WORKING, I CAN USE MY MILEAGE TO FIGURE THAT OUT. BUT THE SPEEDOMETER NOT WORKING IS A REAL ISSUE FOR ME. *TR

TL*THE CONTACT OWNS A 2003 PONTIAC SUNFIRE, WITH COOPER, TREND SETTER SE, SIZE P195/15/R15 REPLACEMENT TIRES. WHILE DRIVING APPROXIMATELY 65 MPH THE PASSENGER FRONT TIRE SEPARATED AND THE TREAD SEPARATED FROM THE STEEL BELT. THE CONTACT WAS ABLE TO DRIVE SAFELY ONTO THE EMERGENCY LANE. THE CONTACT SATED THE TIRE DID NOT DEFLATE; HOWEVER, THE WHEEL WELL AND THE REAR TIRE WERE DAMAGED. THE TIRE WAS REPLACED AT A LOCAL REPAIR SHOP. THE LOCAL MECHANIC STATED THAT THE FRONT DRIVER SIDE TIRE WAS ALSO CRACKED. A POLICE REPORT WAS FILED. THE FAILURE AND CURRENT MILEAGE WERE 90,000. UPDATED 12/30/10

TL*THE CONTACT OWNS A 2003 PONTIAC SUNFIRE. THE CONTACT STATED THAT ALL OF THE GAUGES ON THE INSTRUMENT PANEL STOPPED FUNCTIONING WHILE SHE WAS DRIVING 50 MPH. THE VEHICLE WAS TAKEN TO A LOCAL MECHANIC WHO STATED THAT THE INSTRUMENT CLUSTER MALFUNCTIONED. THE CURRENT AND FAILURE MILEAGES WERE APPROXIMATELY 70,000.

FAILURE TO THE HEADLIGHT HARNESS, WITH TIME, CORROSION ATTACK THE HEADLIGHT HARNESS. WHICH WILL CAUSE THE HEADLIGHT INTENSITY TO LOWER OR WORST, TOTAL HEADLIGHT FAILURE. THAT MEAN THAT YOU CAN BE DRIVING AT NIGHT AND TOTALLY LOSE YOUR HEADLIGHT. THIS DEFECT HAS BEEN REPAIRED 4 TIMES NOW, AND I NEED TO HAVE IT REPAIRED A 5TH TIME APRIL 2004. *TR

2003 PONTIAC SUNFIRE. HEADLAMPS DO NOT WORK. FOUND OUT THRU INTERNET SEARCH THIS IS A COMMON PROBLEM ON THIS VEHICLE. THERE ARE MULTIPLE WIRING PROBLEMS WITH THIS VEHICLE THAT GM SHOULD FIX (FOG LAMPS AS WELL). THE LAMPS ALREADY WENT OUT A COUPLE OF TIMES BEFORE. IT IS A SAFETY HAZARD BECAUSE IF THIS HAPPENS AT NIGHT YOU HAVE NO LIGHTS. GM KEEPS SKIRTING AROUND THE ISSUE UNTIL YOUR WARRANTY RUNS OUT THEN IT COSTS YOU MORE MONEY THAN YOU HAVE TO GET IT FIXED. VERY, VERY, VERY FRUSTRATING. JUST DO A INTERNET SEARCH FOR SUNFIRE HEADLIGHT PROBLEMS/DO NOT WORK/ ETC. AND YOU'LL SEE. *TR

I PURCHASED THE CAR IN 2006 WITH EVERYTHING ON IT STOCK. IN 2009 THE COIL PACK STARTED MISFIRING CAUSING THE CATALYTIC CONVERTER TO GO BAD AND ALSO CAUSING THE RODS BEARINGS TO SPIN. *TR

1. HIGH USE OF TRANSMISSION SHIFT CABLE LEADS TO SEPARATION AT THE TRANSMISSION END LINK. 2. ONCE THE SHIFT CABLE LINK WEARS OUT IT FALLS DOWN AND THE TRANSMISSION CAN NO LONGER BE SHIFTED THROUGH GEAR POSITIONS FROM WITHIN THE VEHICLE. A VEHICLE CAN BE LEFT STRANDED IN ANY GEAR, DRIVE, REVERSE, NEUTRAL, OR ANY OTHER POSITION. 3. A TEMPORARY FIX IS POSSIBLE WITH A ZIP TIE, BUT IS ONLY TEMPORARY DUE TO HEAT AND WEAR ON THE ZIP TIE. AN OE REPLACEMENT FOR THE SHIFT CABLE NEEDS TO BE INSTALLED. THIS IS A HIGH FAILURE ITEM LEADING TO STRANDED VEHICLES IN MANY DANGEROUS LOCATIONS AND NEEDS TO BE UPGRADED WITH A FAIL SAFE CONNECTION AT THE TRANSMISSION END. *TR

TL*THE CONTACT OWNS A 2003 PONTIAC SUNFIRE. WHILE DRIVING APPROXIMATELY 40 MPH AT NIGHT, THE HEADLIGHTS SUDDENLY BECAME EXTREMELY DIM. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER AND REPAIRED ACCORDING TO A SAFETY RECALL. THE VEHICLE WAS TAKEN BACK TO THE DEALER ON THREE SEPARATE OCCASIONS FOR IDENTICAL FAILURES, BUT THE REPAIRS DID NOT CORRECT THE ISSUE. THE NHTSA CAMPAIGN ID NUMBER WAS UNKNOWN. THE FAILURE MILEAGE WAS 3,000 AND THE CURRENT MILEAGE WAS UNKNOWN.

HEAD LIGHTS FAIL FOR NO REASON AND AT ANY TIME. THIS CAN INCLUDE BOTH HIGH AND LOW BEAM AND FOG LIGHTS. HAS BEEN REPAIRED NOW FOR THE 5TH TIME AT A GM DEALER SHIP. *TR

TL*THE CONTACT OWNS A 2003 PONTIAC SUNFIRE. THE CONTACT STATED THAT THE DRIVER'S SIDE HEADLIGHT WAS NOT WORKING ON THE VEHICLE. THE FORWARD ELECTRIC HARNESS ALLOWED WATER TO ENTER INTO THE LIGHT AND CAUSED IT TO FAIL. SOON AFTER PURCHASING THE VEHICLE IN 2003, THE HEADLIGHTS FAILED. THE DEALER INFORMED HIM THAT THERE WAS A RECALL (GM RECALL NUMBER 03029) ON THE LIGHTS. THE VEHICLE WAS REPAIRED BECAUSE IT AFFECTED THE SIGNAL LIGHTS AND DRIVER'S SIDE HEADLIGHT. THE CONTACT RECENTLY TOOK THE VEHICLE BACK TO THE DEALER FOR REPAIR, BUT THEY STATED THAT IT WAS PREVIOUSLY REPAIRED AND WOULD NOT BE REPAIRED A SECOND TIME. THE FAILURE MILEAGE WAS 8,700. UPDATED 03/23/09. *LJ UPDATED 03/24/09.*JB

THE FRONT WIRING HARNESS ON MY 2003 PONTIAC SUNFIRE 2 DOOR HAS FAILED FOR THE 4TH TIME DUE TO CORROSION OF THE OBVIOUSLY-TOO-SMALL GAUGE WIRING AND INAPPROPRIATE PLACEMENT AND WATER-PROOFING OF THE WIRING HARNESS AND CONNECTORS. HEADLIGHT(S) OR FOGLIGHT(S) TYPICALLY EITHER FAIL OUTRIGHT, OR DIM TO ABOUT 10% INTENSITY, CAUSED BY CORROSION IN THE WIRES AND CONNECTORS. PREVIOUS FAILURES OF THIS WIRING HARNESS AFFECTING BOTH HEADLIGHTS AND/OR FOGLIGHTS OCCURRED IN JAN 2005, JAN 2006, AND JAN 2007, AND WERE REPAIRED BY REMOVAL OF CORRODED WIRE SECTIONS AND RE-SPLICING OF WIRES. DISCUSSIONS WITH BOTH GM AND INDEPENDENT MECHANICS CONFIRM MY SUSPICIONS OF SIMILAR FAILURES IN MANY OTHER SUNFIRES AND CAVALIERS. I AGREE WITH A LIFELONG MECHANIC WHO SAYS THE ONLY PROPER SOLUTION IS A COMPLETE REWIRING JOB. THIS IS AN EXTREME HAZARD AS COMPLETE HEADLIGHT FAILURE OR DIMMING CAN HAPPEN ANY TIME WITHOUT WARNING. A DEAD OF NIGHT FAILURE ANYWHERE, IN THE CITY, NEAR A SCHOOL, OR ON A COUNTRY ROAD AS HAPPENED TO MY DAUGHTER'S FRIEND IN HER SUNFIRE, CANNOT BE CONSTRUED AS ANYTHING OTHER THAN LIFE-THREATENING; FOG LIGHT AND HEADLIGHT FAILURE AT ANY OTHER TIME IS DANGEROUS. IF THE FAILURE OF SUNFIRE/CAVALIER REAR BRAKE AND TURN LIGHTS WARRANTED A 2004 RECALL, THEN SURELY THIS EQUALLY OR MORE THREATENING CHRONIC PROBLEM DESERVES ONE. WHY THIS HAS NOT BEEN ADDRESSED ALREADY IS BEYOND ME. GM HAS ACKNOWLEDGED THE PROBLEM BY ISSUING A SERIES OF TSBS OVER THE YEARS ON THIS PROBLEM: #03018, #0309, #030842002, #021903, AND THE NHTSA HAS BEEN APPRISED OF THEM. I AM A HOBBY MECHANIC WHO HAS SPENT 45 YEARS BUILDING AND RACING POWERBOATS AND WORKING ON AND RESTORING CARS. I KNOW A DESIGN FAULT WHEN I SEE ONE. THIS ISSUE MUST BE ADDRESSED BEFORE SOMEONE IS KILLED OR SERIOUSLY INJURED. THE SUSPECT WIRING HARNESSES SHOULD BE RECALLED AND REPLACED, RATHER THAN WAITING FOR THEM TO FAIL (TIME AND TIME AGAIN) AND THEN MAKING SPLICES TO THE WIRING AND CLEANING UP THE CONNECTORS. *TR

I HAVE HAD ALOT OF SHORTAGES ON MY 2003 PONTIAC SUNFIRE. I HAVE BEEN RESEARCHING ON LINE AND THERE HAVE BEEN ALOT OF SIMILAR ISSUES. SUCH AS POWER WINDOW SHORTAGES, HIGH BEAM AND LOW BEAM SHORTAGES, THE LOCKS, AND ISSUES WITH THE DASHBOARD GAUGES NOT WORKING. I FEEL THAT THIS IS TO MANY ISSUES WITH SHORTAGES AND IT IS A SAFETY ISSUE. *TR

THE 2003 PONTIAC SUNFIRE IS AN INFERIOR CAR. MINE CURRENTLY HAS APPROX 57,000 MILES ON THE ODOMETER. THE DAY AFTER I PURCHASED IT BRAND NEW, IT WOULD NOT START. THE DEALER CAME OUT AND REPLACED THE BATTERY. THE CAR HAD WHITE PAINT OVERSPRAY ON IT. THE DEALER REPAINTED IT. THE SUNROOF MALFUNCTIONED AND THE DEALER FIXED IT. THE TURN SIGNALS KEPT GOING OUT & IT WAS FIXED DUE TO THE RECALL. THE DASH HAD TO BE TAKEN OUT DUE TO THE FACT THAT THE AIR WAS NOT COMING OUT OF THE VENTS PROPERLY. THE POWER WINDOW DRIVER'S SIDE FAILED COMPLETELY AROUND 38,000 MILES & PASSENGER INTERMITTENTLY WOULD NOT WORK. THIS WAS FIXED AT MY EXPENSE. THE CAR HAS BEEN IN THE SHOP FOR BRAKE PROBLEMS NUMEROUS TIMES. I HAD THE DEALER CHECK THEM SEVERAL TIMES WHILE STILL UNDER WARRANTY AND THEY FINALLY REPLACED THEM AT THEIR COST BECAUSE THEY SAID IT SHOULD NOT BE NECESSARY GIVEN THE MILEAGE ON THE CAR. I'VE HAD BRAKES REPLACED TWO OTHER TIMES AT MY EXPENSE AND THEY ARE STILL SQUEAKING AND CREAKING VERY LOUDLY AND I'M TOLD THE BRAKE PADS ARE "CRACKED" BUT THAT IT WON'T HURT ANYTHING. NOW, THE NEW PROBLEM IS, THE RADIO QUIT PLAYING FOR 15 MINUTES AFTER THE CAR IS TURNED OFF AND YOU'RE IN IT. WHEN I COME TO A COMPLETE STOP, MY DOME LIGHT AND MAP LIGHTS COME ON AND STAY ON UNTIL I LET OFF THE BRAKE AND ACCELERATE. ALSO, THE HORN NO LONGER HONKS WHEN I LOCK THE CAR WITH THE REMOTE. I'VE HAD IT UP TO HERE WITH THIS CAR BUT CANNOT AFFORD TO GET RID OF IT SINCE I JUST PAID IT OFF IN JULY 2008. I WILL NEVER BUY ANOTHER PONTIAC! *TR

2005 HEADLIGHTS WENT OUT WHEN DRIVING AT NIGHT - PONTIAC DEALER WRAPPED HARNESS WITH ELECTRICAL TAPE. STATED IT WAS FROM WASHER FLUID LEAKING. APPROX 12 MONTHS LATER INCIDENT OCCUR AGAIN. TAKEN TO ANOTHER DEALER ON REQUEST OF PONTIAC. RE-WRAP HARNESS DIFFERENT AREA. SERVICE LIGHT ON 2 WEEKS AGO. DEALER WRAPPED ENTIRE HARNESS. PONTIAC SERVICE NOTIFIED SEVERAL TIMES COMPLAINT NUMBERS OBTAINED. SAFETY ISSUE AS LIGHTS GO OUT. WIRING HARNESS DETERIORATED. BANDAIDED 3X. CONCERN RE: LIGHTS GOING OUT AGAIN AT NIGHT. FEEL THIS IS A DANGEROUS SITUATION. *TR