2010 Volvo Xc90
The Verdict
The 2010 Volvo Xc90 has 12 owner complaints filed with NHTSA. The most reported issues are body (6 complaints) and engine (4 complaints). With a Klunk Score of 97/100, it earns a "Smooth Ride" rating. If you're shopping for a Volvo Xc90, consider the 2012 model year which has 75% fewer complaints.
Safe Bet
The 2012 has 75% fewer complaints
View the 2012 Volvo Xc90 dashboard →
Klunk Score: Smooth Ride
This vehicle year has significantly fewer complaints than average. A reliable choice.
How is this calculated?
The Klunk Score ranks this vehicle year against all others in our database based on total owner complaints filed with NHTSA. 100 = fewest complaints (top tier), 0 = most complained-about. Scores above 60 are better than average; below 40 means more problems than most.
Recalls 2
Active safety recalls from NHTSA for this vehicle year.
VOLVO IS RECALLING CERTAIN MODEL YEAR 2010 XC90 VEHICLES. A LEAK MAY DEVELOP IN THE FUEL LINE BETWEEN THE LINE AND A CONNECTOR.
Risk
FUEL ODOR MAY BE DETECTED. A FUEL LEAK IN THE PRESENCE OF AN IGNITION SOURCE CAN LEAD TO A FIRE AT THE RIGHT FRONT WHEEL.
Remedy
DEALERS WILL INSPECT THE DATE CODE PRINTED ON THE FUEL LINE AND REPLACE THE FUEL PRESSURE LINE IF IT FALLS WITHIN THE RECALLED RANGE FREE OF CHARGE. THE RECALL BEGAN ON APRIL 23, 2010. OWNERS MAY...
Reported Apr 11, 2026
VOLVO IS RECALLING CERTAIN MODEL YEAR 2010-2011 XC90 VEHICLES MANUFACTURED FROM JANUARY 29, 2010, THROUGH AUGUST 16, 2010. THE POWER STEERING FLUID MAY LEAK FROM THE OIL PIPE CONNECTION AT THE STE...
Risk
THIS CONDITION COULD LEAD TO A SUDDEN LOSS OF POWER STEERING, INCREASING THE RISK OF A CRASH.
Remedy
DEALERS WILL REPLACE THE OIL PIPES ON THE POWER STEERING RACK FREE OF CHARGE. THE RECALL IS SCHEDULED TO BEGIN DURING JUNE 2011. OWNERS MAY CONTACT VOLVO AT 1-800-458-1552.
Reported Apr 11, 2026
Get notified if a recall hits this car.
We email you when NHTSA issues a new recall on the 2010 Volvo Xc90. No spam, no marketing.
Under the Hood
Each number is a complaint. Darker = bigger problem.
By Category
By Severity
Worst Problems
Complaints
The contact owns a 2010 Volvo XC90. The contact stated while driving 70 MPH, the vehicle stalled with the check engine warning light illuminated. The contact attempted to restart the vehicle, but the failure persisted. Due to failure, the vehicle was towed to the residence. An independent mechanic arrived at the residence and discovered a leak in the fuel line. Upon investigation, the contact linked the failure to NHTSA Campaign Number: 10V147000 (Fuel System, Gasoline). The vehicle was not repaired. The failure mileage was approximately 125,000.
I WAS DRIVING MY WHEEL LOCKED I CANNOT TURN MY WHEEL
ENGINE STALLED AND SHUT DOWN AT HIGHWAY SPEED OF APPROXIMATELY 70 MPH. TWO CONSECUTIVE TANKFULS AT ABOUT 1/4 TANK OR 135 MILES TO EMPTY. CHECK ENGINE LIGHT CAME ON. RESTARTED ENGINE AND LIMPED TO NEAREST GAS STATION. AFTER FILLUP ENGINE LIGHT CLEARED AND IT DROVE FINE UNTIL DOWN TO APPROX A QUARTER TANK AGAIN WHEN IT REOCCURRED.
THE VEHICLE GETS A STRONG GAS SMELL INSIDE THE DRIVING AREA WHEN GAS TANK FILLED. NO FUEL FOUND TO BE LEAKING. SMELL COMES FROM UNDER FLOOR BY BACKSEATS
STEERING OFTEN SHAKES AND IS HARD TO CONTROL GOING OVER 50 MILES PER HOUR. STEERING COLUMN STICKS AT TIMES AND THEN IS VERY WOBBLY.
DROVE VOLVO ONE DAY AGO AND WHILE DRIVING ON RURAL HIGHWAY ROAD EARLY MORNING IN THE DARK, VEHICLE WITHOUT WARNING TOTALLY SHUT DOWN IN MIDDLE OF ROAD AND STALLED OUT. HAD TO VEER OFF ROAD AND COAST ON INCLINE WITH NOT MUCH MOMENTUM DUE TO CARS BEHIND ME. WAS DANGEROUS SITUATION, BUT LUCKILY GOT VEHICLE INTO SMALL DITCH OFF ROAD . HAD TO BE TOWED TO GARAGE AS WOULD NOT RESTART. WAS ADVISED BY VOLVO DEALER AFTER DIAGNOSTIC THAT FUEL PUMP WAS BAD AND PART BURNED OUT INSIDE IT AND NEEDS REPLACED. ABOUT A LITTLE LESS THEN A YEAR AGO VEHICLE BEGAN TO SHAKE UPON START AND WANTED TO STALL, WAS CHECKED OUT AND THOUGHT MAYBE BAD GAS AS NO FURTHER SYMPTOMS. NOTHING HAPPENED AFTER AND CAR RAN NORMALLY UNTIL INCIDENT 1 DAY AGO.
TL* THE CONTACT OWNS A 2010 VOLVO XC90. THE CONTACT STATED THAT THE DASHBOARD HAD DETERIORATED TO THE POINT WHERE IT WAS STRUCTURALLY UNSOUND AND BUCKLING IN THE AREA OF THE FRONT PASSENGER SIDE AIR BAG COMPONENT. THE DEALER (VOLVO ESCONDIDO, 1938 AUTO PARK WAY, ESCONDIDO, CA 92029) WAS NOTIFIED AND STATED THAT THE FAILURE COULD HAVE BEEN CAUSED BY EXTREME HEAT. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS NOT AVAILABLE.
THE DRIVERS SIDE VIEW MIRROR HAS LOOSENED WITHOUT EVIDENCE OF TRAUMA. IT IS DIFFICULT TO MAINTAIN VISIBILITY WITHOUT OPENING THE WINDOW AND MANUALLY PUSHING THE MIRROR CASING OUTWARD. IT MOVES WHEN THE CAR IS IN MOTION AND WHEN STATIONERY.
THE SPARE TIRE CABLE ASSEMBLY BROKE, CAUSING SPARE TIRE TO DROP FROM UNDER VEHICLE WHILE PARKED IN GARAGE. THE CABLE ASSEMBLY DISMOUNTED FROM THE CARRIER NUT. SPARE TIRE HAS NEVER BEEN USED MY OWNER. IF VEHICLE WAS TRAVELING ON ROAD AT TIME OF CABLE MALFUNCTION, WOULD HAVE CAUSED AN ACCIDENT OR POSSIBLE DEATH. PLEASE ADVISE!
STARTLINGLY LOUD POP WHEN DRIVING AT 70MPH ON INTERSTATE. PULLED OFF TO CHECK TIRES IN THICK MORNING RUSH HOUR TRAFFIC AND DID NOT NOTICE SUNROOF HAD SHATTERED UNTIL SOME MILES LATER WHEN I CONTINUED TO HEAR GRAVEL ROLLING AROUND ON TOP OF MY CAR. A LARGE CHUNK OF WINDOW HAD FLOWN OFF THE BACK, APPARENTLY. FORTUNATELY, SCREEN WAS CLOSED. AND,THE CARS BEHIND ME WERE NOT EFFECTED. I DO NOT RECALL ANYTHING HITTING THE SUNROOF NOR WAS I BEHIND ANY TRUCKS THAT MAY HAVE HAD LOOSE ROCKS. COST TO REPAIR IS $935!!, ALL OUT OF POCKET SINCE MY DEDUCTIBLE IS $1000. THIS SHOULD NOT HAVE HAPPENED! VOLVO SERVICE TELLS ME THIS HAPPENED TO ANOTHER CAR RECENTLY!!
I PULLED DOWN THE SPARE TIRE IN OUR 2010 XC90 TODAY TO REPAIR A FLAT (I THINK THIS MAY BE THE FIRST TIME WE HAVE HAD TO DO SO). THERE ARE 4 LARGE BURNED AND MELTED AREAS (AS IF IT HAD BEEN ON A GIANT GRILL) ON THE SIDEWALL OF THE SPARE TIRE THAT FACES THE UNDERCARRIAGE WHERE IT IS SUSPENDED UNDERNEATH THE REAR OF THE VEHICLE. I ASSUME THIS IS FROM THE MUFFLER OR SOME OTHER HOT METAL. IN ADDITION TO WONDERING IF THIS IS A FIRE HAZARD, I AM ALSO APPREHENSIVE ABOUT THE INTEGRITY AND SAFETY OF THE SPARE TIRE ONCE IT IS PLACED ON THE CAR. *TR
TL* THE CONTACT OWNS A 2010 VOLVO XC90. THE CONTACT STATED WHILE THE VEHICLE WAS PARKED IN HER GARAGE, THE SPARE TIRE BECAME DETACHED FROM THE VEHICLE. THE VEHICLE WAS TAKEN TO THE DEALER AND THE TECHNICIAN DIAGNOSED THAT THE WINCH THAT WAS HOLDING THE SPARE TIRE IN PLACE FRACTURED, CAUSING THE FAILURE. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE VIN WAS NOT AVAILABLE. THE FAILURE AND CURRENT MILEAGE WAS 60,000.