Ford F-150 Engine Problems
2,460 owner complaints filed with NHTSA across 10 model years.
Complaints by Year
Worst year: 2001. Best year: 2009.
Owner Reports
A representative sample of complaints filed with NHTSA.
THE F-150 WAS PARKED IN THE CARPORT ATTACHED TO MY SON'S HOUSE. IT HAD BEEN PARKED AND NOT RUNNING FOR AT LEAST 3 HOURS. A PASSERBY NOTICED THE TRUCK ON FIRE AND TRIED TO WAKE ALL OCCUPANTS IN THE HOUSE(DUPLEX). AT 5 A.M ON 9/11/2008. M...
WELL AT FIRST MY 2001 F-150 SUPERSCRIPT AT 55000 MILES STARTED TO LAG, WHEN I WOULD PRESS THE GAS IT WOULD TAKE A LONG TIME TO PICK UP SPEED OR CHANGE GEARS. THEN ONE DAY I WAS DRIVING HOME FROM WORK GOING ABOUT 55 MPH WHEN I HEAR A LOU...
The contact's son owned a 2009 Ford F-150. The contact stated that while approximately 10 MPH, he observed smoke emanating from the glove box and the check engine warning light illuminated. The contact steered the vehicle to the side of ...
The contact owns a 2005 Ford F-150. The contact stated that while driving at 55 MPH, while the brake pedal was depressed, the brakes failed to engage; the contact pulled the vehicle into a Home Depot parking lot, exited the vehicle, and ...
The contact owned a 1996 N/A Ford F-150. The contact stated that while the vehicle was parked and turned off, the firewall located on the driver's side had caught on fire. The fire was extinguished by the Fire Department. A fire report w...
Vehicle caught on fire from the engine compartment while driving. Total loss, Fire Department responded to the scene. Two persons on board of the vehicle had to escape the fire, pulled over and jumped out.
While driving lost power from 70 mph to 45 mph drove it slow home Once I parked check engine light and noticed smoke coming from behind and lower part of engine after checking for heat source noticed glowing areas it was the insulation ...
The contact owns a 2002 Ford F-150. The contact stated that she observed smoke emanating from under the vehicle near the engine compartment. The contact stated that she opened the hood and flames erupted from the engine compartment near ...
The contact owned a 2006 Ford F-150. The contact stated that while driving at a low rate of speed, an abnormal, popping sound emitted from the vehicle without warning. Soon after he heard the sound, the vehicle caught fire. The contact e...
On 11/27/2022 at or around 4:30 P.M. my 2003 Ford F-150 burned almost completely, without any mechanical failures or warnings, thirty full minutes after being parked and then after only having been run for three to four miles. The fire d...
Unknown cause of incident. Vehicle is available for inspection. Vehicle spontaneously burst into flames. No reproduction due to incident happening on 09/02/2022. Vehicle inspected by Fire Department and California Highway Patrol. No warn...
The contact owns a 2008 Ford F-150. The contact stated while driving at approximately 40 MPH and rounding a right-hand bend, the steering wheel veered to the left direction. The contact stated the "tire pressure" warning light was illumi...