2021 Lincoln Nautilus

Drivers front door inner sheet metal structure has failed/torn at the check arm mounting points under normal operating conditions.. safety hazard. Dealership and Lincoln will not take full responsibility after known structural defect exists. I note on your website that in Nautilus alone there are 10 complaints including mine. Our car had less than 42,000 miles when we noticed. The entire door needs to be replaced.

Drivers front door inner sheet metal structure has failed/torn at the hinge and check arm mounting points under normal operating conditions.. safety hazard. Dealership and Lincoln will not take full responsibility after known structural defect exists

Both front doors on my 2021 Nautilus Reserve have structural stress cracks in the sheet metal surrounding the check-arm bracket, along the edge of the recessed mount and under the weatherstrip. I first noticed cracking and popping when opening and closing the doors on 8/1/2026 at about 84,000 miles. No collision; normal use. The bracket mounts to the inner door panel with no reinforcement. The panel visibly flexes every time the door opens and checks, and that flexing has fatigued and cracked the metal. The cracks are growing. This is a safety issue. Once the bracket tears out, the door has no hold-open or stop. It can be pulled open by wind, strike a person or vehicle beside it, or swing closed on an occupant's arms or legs. Complaint 11767021 reports a 2021 Nautilus door torn from the owner's hand by wind after the check broke. In PE23-013, NHTSA's investigation of the same failure on the Ford Escape, NHTSA documented 25 injuries, mostly from doors closing on occupants, and cited risk of a door failing to latch, failing to open, or opening while driving. Both my front doors are affected, so the driver and passenger exits are both at risk. At least eight other 2021 Nautilus owners have filed NHTSA complaints on the same failure, and Ford Edge owners report it too. Ford covers this failure on the 2020-2023 Escape under CSP 23B56 (reinforcement plate or new door, no cost, no mileage limit), but no recall or program covers the Nautilus or Edge. Lincoln (case CXH-09573152) offered $4,400 goodwill instead of a full repair. Other 2021 Nautilus owners report this failure as early as 20,000 miles, so it is a design flaw, not wear. Re-welding or installing the same unreinforced door will not fix it; any remedy must add reinforcement at the check-arm mount. I request an investigation of front door check-arm related stress cracking on doors of 2019-2023 Nautilus and Edge vehicles. Photos, video, and an evidence brief are available.

Transmission was shuddering when it shifted gears. It would lose power and jerk between each gear. We paid for diagnostic at the dealership and they diagnosed as torque converter shudder under 2 separate TSB's. Dealership offered to fix at a cost of $6400. Told not to drive the vehicle or at least as little as possible. They refused to cover this under the TSBs. Contacted Lincoln Client Care. The shudder became worse even driving through town and it would jerk and the RPMS were jumping all over. Also took it to AAMCO after dealership stated they would not cover it under a TSB. AAMCO provided free diagnostic and came to the same conclusion of the torque converter and estimated cost of $3300, which was 3100 less than dealership. Asked Lincoln for goodwill fix and they spent a month talking to the dealership trying to get the dealership to a lower price, to whichthe dealership raised the price to $6800 and they offered 4k in goodwill, but said that it would take 4 to 6 weeks to get the parts. By this time AAMCO already had the parts after waiting3 weeks on backorder and AAMCO made te fix at an out of pocket cost of $3300. Total out of pocket costs were the 300 for the diagnostic and the 3300 for the torque converter fix.

Noticed cracking sound when opening and closing front drivers door. Subsequently discovered same issue on Ford Edge (recall in place) and many other owners having same problem (FaceBook posts).

Door check is broken in high winds the door pulled out my hand. Could have injured someone of that person was standing near the opening path of the door.

The driver's side door is cracked at the door hinge assembly. This is a widely documented defect. My door cracked at 50,000 miles. There are thousands of 2019-2024 Nautilus's with this defect. Lincoln wants $5,000 to replace the door. They offered $2,000 toward the repair. This should be a recall.

The door broke and cracked the window when I opened the door to get in the car

The contact owns a 2021 Lincoln Nautilus. The contact stated that while the vehicle was at the dealer for an oil change and trade-in, the contact was informed that the front driver’s side door had a crack and that the welding was cracked and loosened. The vehicle was not repaired. The manufacturer was made aware of the failure, and a case was filed. The failure mileage was approximately 92,800.

The transmission occasionally jerks/studders between second and third at acceleration and deceleration.

2021 Lincoln Nautilus Reserve 2.7-liter twin-turbocharged V6 with coolant intrusion caused by a blown head gasket on cylinder #6. Vehicle would not accelerate properly and lurch forward when the gas pedal was pressed over 25%. The issue was taken to the shop and not found. The issue progressed and was taken to the shop a second time. The issue was found from a misfire code on cylinder #6. Vehicle is currently being repaired.

Vehicle died in parking lot. The electronics all worked, it just would not start and would not go into any gear. Had to have it towed to dealer for repair. They replaced the PCM but it still would not start. They again replaced the PCM and a fuse. The vehicle started. This is the FOURTH time for the exact same issue. It died twice on the previous owner, once while on the highway. It also died twice for the mechanic while trying to diagnose / test drive the unit for the previous owner. We were lucky it died where it could be towed as it's an all wheel drive unit. It has also had an O2 sensor replaced, and the previous owner suffered wiring issues (replaced the engine bay body harness), sunshade recoil failed, abnormal noise in rear end when turning, etc. All issues were corrected. However, I am uncomfortable that these issues may re-occur. Another failure of the PCM and/or electrical issue could cause the unit to die in a situation that could be life threatening.

While driving on the highway my transmission died. Had it towed to a nearby forwad dealershiop, Owens Ford in Jarrett VA and they confirmed the transmission died at 51,600 miles.

The contact owns a 2021 Lincoln Nautilus. The contact stated that while opening the front driver’s door, there was a cracking sound coming from the door. While the vehicle was in for routine maintenance, the mechanic discovered that the front driver’s side door check arm stop bracket and door hinge were faulty. The vehicle was taken to the local dealer, who examined the vehicle and informed the contact that the front driver’s side door needed to be replaced. The vehicle was not yet repaired. The manufacturer was notified of the failure. The contact stated that the vehicle was previously repaired for the same failure. The failure mileage was 74,000.

Door check and spot welds are broken. The car has less the 20,000 miles on it. I was told by the mechanic that he saw this issue with Ford Escapes, there was a recall on the drive side door for the welds failing.

The contact owns a 2021 Lincoln Nautilus. The contact stated that while shifted to reverse(R) and depressing the accelerator pedal, the vehicle hesitated and then suddenly jerked backwards. The contact stated that the vehicle almost jumped into gear. The contact stated that later while driving and attempting to accelerate, the accelerator pedal was depressed and the vehicle hesitated and then jolted forward. The vehicle accelerated to approximately 60 MPH. The contact depressed the brake pedal, and the vehicle was jerking while attempting to slow down. The contact was able to stop the vehicle at a traffic light. The contact stated that the "WRENCH" symbol was displayed on the instrument cluster. The contact drove the vehicle back to the residence and then the vehicle was towed to an independent mechanic to be diagnosed. The mechanic had not diagnosed the vehicle but advised the contact that it was possibly a transmission failure and referred the contact to the dealer for assistance. The vehicle was towed to the local dealer. The dealer diagnosed the vehicle and determined that the transmission needed to be replaced. The vehicle was not repaired. The manufacturer was informed of the failure and advised the contact that there were no recalls associated with the VIN for the transmission. The failure mileage was approximately 101,000.

The contact owns a 2021 Lincoln Nautilus. The contact received notification of NHTSA Campaign Number: 25V315000 (Back Over Prevention); however, the part to do the recall repair was not yet available. The local dealer was contacted. In addition, it was noticed that the VIN was no longer associated with NHTSA Campaign Number: 25V315000 (Back Over Prevention). The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure.

The contact owns a 2021 Lincoln Nautilus. The contact stated while driving at an undisclosed speed, the accelerator pedal was depressed; however, the vehicle failed to accelerate as intended. In addition, the transmission was slipping, and the RPM had increased significantly. The contact stated that the “Service Vehicle Soon” message was displayed. The vehicle was taken to the dealer where it was diagnosed with transmission failure. The contact was informed that the transmission needed to be replaced. The vehicle was not repaired. The manufacturer was not made aware of the failure. The failure mileage was approximately 86,000.

My doors are totally broke. Has no swing stop. Broke so bad the medal is torn

Since 2023 there has been an ongoing issue with my vehicle. When Im in public parking lots and I am accessing the trunk. I’ve witnessed my trunk literally shutting down or closing as Im accessing the trunk. Ive recorded this safety concern and Ive reported it to the dealership and manufacturer. The last time this serious issue occurred was last Friday, May 9, 2025. I was loading the trunk with my purchases as the trunk began closing. Whatever is causing this to occur. Ive noticed that the safety feature that signals the trunk to stop closing when it detects an object in the way becomes disabled. The trunk does not stop closing when Im underneath it. Ive witnessed my trunk sporadically closing at least four to five times on Friday. I was able to record one time that it closed as I said it kept happening sporadically. On the same day, I called the dealership and left a message with one of the contact people. As of today, May 13, 2025. I haven’t not gotten a response. This is a safety and security issue that needs to not only be addressed but resolved. And I am not getting help with either of the two.