2002 Chevrolet Venture

The contact owns a 2002 Chevrolet Venture. The contact stated that while the vehicle was parked, a fuel odor was detected inside the cabin of the vehicle. Additionally, the vehicle was consuming an excessive amount of fuel. The contact's neighbor, an independent mechanic, diagnosed that there was fuel leaking between the connection of the fuel line and fuel tank. The vehicle was not repaired. The manufacturer was not made aware of the failure. The failure mileage was approximately 80,000.

BLOWN INTAKE MANIFOLD GASKET. VEHICLE DID NOT HAVE AN OVERHEATING ISSUE, AND HAS BEEN WELL MAINTAINED SINCE I'VE OWNED IT. DROVE ACROSS A STEEP 7 MILE HILL, TEMP GAUGE STARTED MOVING ABOVE NORMAL. I STOPPED AND LET IT COOL DOWN, MOTOR GOT TO ABOUT 245 DEGREES WELL BEFORE ANY WARNING LIGHTS WERE ABLE TO COME ON. STARTED THE MOTOR AND IT SOUNDED DIFFERENT SO I POPPED THE HOOD AND THE COOLANT OVERFLOW WAS BUBBLING. NOTICED THE WINDSHIELD STARTED STEAMING UP, AND A VERY ROUGH IDLE. SHUT THE MOTOR OFF AND STARTED IT AGAIN. WHITE SMOKE COMING FROM THE TAILPIPE. TURN IT OFF AGAIN AND OPENED THE OIL CAP AND IT HAD THE MAYO LOOK AND SMELLED OF ANTIFREEZE. PULLED THE DIPSTICK AND THE OIL WAS BROWN AND SEPARATED. GOT IT HAULED HOME. DID AN INSPECTION AND ANTIFREEZE WAS ALL DOWN THE BLOCK. TOOK THE MOTOR APART AND THE LOWER INTAKE MANIFOLD GASKET WAS JUST DETROYED. CHEVROLET HAS HAD NOTHING BUT PROBLEMS OUT OF THESE 3.4 GEN 3 MOTORS. THEY ALL NEED TO BE RECALLED AND THE PROBLEM CORRECTED. DOESN'T MATTER IF YOU KEEP THE COOLANT FLUSHED AND OIL CHANGED. HEAD GASKETS WERE IN THE SAME SHAPE I CHANGED THEM TOO. ALL TOGETHER COST ME OVER $1000 BETWEEN GASKET KITS, HEAD BOLTS, INTAKE BOLTS, COOLANT, OIL, FILTER, FLUSH, AND THAT WAS CHANGING THE HEAD GASKET, LOWER AND UPPER INTAKE MANIFOLD GASKET COMPLETELY BY MYSELF. THESE MOTORS ARE SO HARD TO WORK ON, I JUST COULDN'T AFFORD TO HAVE SOMEONE DO IT FOR ME. IT'S JUST BAD TO BUY A VEHICLE AND HAVE THIS PROBLEM. MOST VENTURE OWNERS HAVE CHANGED HEAD GASKETS OR INTAKE GASKETS MORE THAN ONCE. TOYOTA RECALLED THEIR 3.0 MOTORS FOR THIS PROBLEM, WHY IS GM NOT MADE TO RECTIFY THIS CONTINUOUS PROBLEM. THE VAN HAS ALOT OF OTHER PROBLEMS AS WELL, BODY RUST, HEADLIGHTS YOU CANNOT SEE WITH, OIL SEAL LEAKS, STEERING KNUCKLE PROBLEMS, SLIDING DOOR ISSUES, RADIO PROBLEMS, ELECTRICAL PROBLEMS, SIGNAL LIGHTS, ABS PROBLEMS. FUEL PUMP PROBLEMS. IT'S A LEMON

SUDDENLY MY VEHICLE HAD A STRONG GASOLINE ODOR WHEN I WALKED UP ON IT IN THE MORNING I SMELLED IT 3 FEET AWAY FROM MY VEHICLE. IT HAPPENED JUST LIKE THAT ALL OF A SUDDEN. I SCHEDULED MY INSPECTION WITH MY MECHANIC AND I TOLD HIM I SUDDENLY WAS SMELLING A STRONG ODOR OF GAS. MY MECHANIC CALLED AND INFORMED ME THERE WAS A CRACK IN MY GAS TANK AND IT IS LEAKING SO THAT IS WHY I WAS SMELLING GAS SO BADLY. WE ORDERED ANOTHER 2002 CHEVROLET VENTURE GAS TANK FROM A SALVAGE YARD. THEY SHIPPED THE GAS TANK AND WHEN MY MECHANIC OPENED IT IT WAS BROKE IN THE SAME EXACT PLACE. THIS IS WHY I THOUGHT LOOKING UP FOR POSSIBLE RECALL. I FOUND RECALL 07V349000. STATED THE FUEL TANK INLET CHECK VALVE CAN CRACK AND LEAK. STATED AFFECTED CHEVROLET VENTURE 2001, 2002, 2003, 2004. I HAVE 2002. MY PROBLEM IS IT'S VIN SPECIFIC ACCORDING TO CHEVROLET THE NUMBER THAT I WAS GIVEN TO CALL ABOUT THE RECALL. 18006302438. MY VIN NUMBER WAS NOT INCLUDED. MY PROBLEM FITS THE DESCRIPTION PERFECTLY BUT THEY CLAIM THEY CAN'T HELP ME. THIS IS A SERIOUS SAFETY PROBLEM FOR ANYONE. I NOW HAVE TO PAY OVER 1,000.00 FOR A NEW GAS TANK OR HAVE NO CAR. I DO NOT HAVE ANY TRANSPORTATION NOW. MY CHEVROLET VENTURE IS SITTING AT MY MECHANICS.

FUEL FILLER NECK CRACKED WHERE IT IS ATTACHED TO THE GAS TANK. FUEL LEAKING OUT OF NECK.

TL* THE CONTACT OWNS A 2002 CHEVROLET VENTURE. WHILE THE VEHICLE WAS PARKED, THERE WAS STRONG FUEL ODOR EMITTED IN AND AROUND THE VEHICLE. EACH TIME THE VEHICLE WAS PARKED, A PUDDLE OF FUEL WAS SEEN ON THE GROUND. THE CONTACT'S BROTHER, A CERTIFIED MECHANIC, DIAGNOSED THE VEHICLE AND STATED THAT THE TANK WAS CRACKED AT THE INLET CHECK VALVE AND NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE VIN WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBER: 07V349000 (FUEL SYSTEM, GASOLINE). THE MANUFACTURER WAS MADE AWARE OF THE FAILURE AND INFORMED THE CONTACT THAT THERE WAS NO OPEN RECALL PER THE VIN. THE APPROXIMATE FAILURE MILEAGE WAS 140,000.

TAKATA RECALL I WAS DRIVING AND RAN OFF THE EDGE OF THE ROAD AND OVER CORRECTED MYSELF AN HIT AN EMBANKMENT HEAD ON AND MY FACE WENT INTO THE STEERING WHEEL AND THEN WAS THROWN FOR THE VAN OUT THE BACK PASSENGER WINDOW AND THE VAN THEN LANDED ON MY FOOT BEFORE I HIT THE ROAD DUE TO AIR BAG NEVER DEPLOYING MY NOSE WAS TORN ABOUT OFF MY FACE AND BROOK 4 RIBS FRACTURED 5 AND MY FOOT AND ANKLE AND FOOT WAS BADLY DAMAGED MY SEAT BELT WAS PUT ON BUT FOR SOME REASON DIDN'T WORK. *TR

FUEL LEVEL GAUGE DOES NOT WORK EVER SINCE I HAD THIS VAN AND FUEL PUMP UNEXPECTEDLY WENT BAD AT ABOUT 83000 MILES

TL* THE CONTACT OWNS A 2002 CHEVROLET VENTURE. WHILE DRIVING APPROXIMATELY 5 MPH, THE STEERING SNAPPED AND DISENGAGED. THE VEHICLE WAS COASTED TO THE SIDE OF THE ROAD AND WAS TOWED TO THE CONTACT'S RESIDENCE. BASED UPON THE CONTACT'S EXAMINATION, THE GEAR BOX WAS FRACTURED. THE FAILURE WAS NOT DIAGNOSED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 145,000.

SOMETHING BROKE INSIDE STEERING COLUMN , RACK & PINON. 100% LOST CONTROL OF STEERING. VEHICLE WAS IN MOTION WHEN ATTEMPT TO TURN.

TL* THE CONTACT OWNS A 2002 CHEVROLET VENTURE. THE CONTACT NOTICED AN ABNORMALLY STRONG FUEL ODOR COMING FROM THE VEHICLE. THE CONTACT OBSERVED FUEL PUDDLES UNDER THE VEHICLE. THE VEHICLE WAS NOT DIAGNOSED NOR REPAIRED. THE VIN WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBER: 07V349000 (FUEL SYSTEM, GASOLINE). THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 51,000.

TL* THE CONTACT OWNS A 2002 CHEVROLET VENTURE. WHILE THE VEHICLE WAS PARKED, THE DRIVER AND PASSENGER SIDE AIR BAGS SUDDENLY DEPLOYED WITHOUT WARNING. THE CONTACT SUSTAINED INJURIES, BUT DID NOT REQUIRE MEDICAL ATTENTION. THE VEHICLE WAS TOWED TO A DEALER WHERE IT WAS DIAGNOSED, BUT THE CAUSE OF THE FAILURE COULD NOT BE DETERMINED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 143,000. UPDATED 04/06/16*LJ THE CONSUMER STATED THE CHECK ENGINE LIGHT ILLUMINATED. UPDATED 04/19/2016.*JB

TL* THE CONTACT OWNS A 2002 CHEVROLET VENTURE. THE CONTACT STATED THAT ALL THE FUEL FILLER NECKS WERE FRACTURED, WHICH CAUSED FUEL TO LEAK. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE ISSUE. THE FAILURE MILEAGE WAS 160,000.

TL* THE CONTACT OWNS A 2002 CHEVROLET VENTURE. THE CONTACT STATED THAT THERE WAS A FUEL LEAK COMING FROM THE VEHICLE. THE VEHICLE WAS TAKEN TO A DEALER WHERE IT WAS DIAGNOSED THAT THE INLET CHECK VALVE AND THE FUEL TANK NEEDED TO BE REPLACED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE VIN WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBER: 07V349000 (FUEL SYSTEM, GASOLINE: STORAGE). THE APPROXIMATE FAILURE MILEAGE WAS 140,000.

TEMP GAUGE TRYS GO HOT HAD CHECK NOTHING ENGENE MISFIRE HAD CHECK 7 TIMES NOW. REPLACE MASS AIR TEMP SENSORE TWICE THROTTLE POSITION SENSORS. PLUGS AND WIRES TWICE IN ONE MONTH HAS WIRE SHORTAGE FOR AC AND WE HAVE PAID OUT ALOT OF MONEY FROM DAY 2 OF OWNING THIS WAS GOING SELL BUT I WOULD SELL THIS CRAP TO NO ONE.. NOW SAYS O2 SENSORE LEFT WHEEL SENSOR AND MUCH MORE CODES JUNK LIKE THIS DONT NEED TO BE SOLD..

I WAS PULLED OVER DO TO NO REAR BRAKE LIGHT OR TURN SIGNAL ON LEFT SIDE. GOT A TICKET. WENT TO JUNK YARD BOUGHT REPLACEMENT ONLY TO DISCOVER IT WAS ALSO BURNED OUT AND USELESS !!!!!!!!!!!!!! BEEN THROUGH AT LEAST 50 BULBS IN THE LAST YEAR ALONE. I AM SECOND OWNER. ALSO HAVE ANOTHER ELECTRICAL ISSUE AS IN THE SWITCH ABOVE IN BETWEEN FRONT SEATS THAT CONTROL INSIDE LIGHTING. IT MUST STAY IN THE OFF POSITION OR IT RUNS THE BATTERY COMPLETELY DOWN. ALSO THE SIDE DOOR GETS STUCK IN THE OPEN POSITION AND IT TAKES A LOT OF STRENGTH TO CLOSE IT. *TR

ICV (IN LINE CHECK VALVE) HOUSING ON FUEL TANK HAS STARTED CRACKING AND LEAKING FUEL. CHEVROLET SAYS THIS UNIT IS NOT AFFECTED BY RECALL 07V349000. IT APPEARS TO BE THE SAME AS MY OTHER VENTURE WE HAD THE RECALL PERFORMED ON LEAKING AT SAME SPOT. THIS IS A FIRE HAZARD AND GM SHOULD REPAIR THIS ON ALL VENTURE VANS. I HAVE RUN ACROSS HUNDREDS OF PEOPLE IN DISCUSSION WITH SAME ISSUE AND NOT WITHIN GM'S VIN BREAKS. I THINK GM NEEDS TO LOOK AT THIS AGAIN. I HAVE PICTURES TO PROVE WHAT IS GOING ON. *TR

TL* THE CONTACT OWNS A 2002 CHEVROLET VENTURE. UPON REFUELING THE VEHICLE, FUEL STARTED LEAKING FROM THE FUEL TANK. THE CONTACT MENTIONED THAT THE FAILURE PROGRESSIVELY WORSENED. AFTER INSPECTING THE VEHICLE, THE CONTACT NOTICED A SMALL FRACTURE WHICH MAY HAVE ALLOWED FUEL VAPORS AND SMALL DROPLETS OF FUEL TO PASS THROUGH. THE VEHICLE WAS NOT INSPECTED OR DIAGNOSED. THE VEHICLE WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBER: 07V349000 (FUEL SYSTEM, GASOLINE). THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 214,000.

ON THE WAY TO TAKING MY SON TO WORK, I NOTICED A LOUD BUZZING SOUND COMING FROM THE REAR PASSENGER SIDE OF MY 2002 CHEVY VENTURE VAN. UPON CHECKING THE DASHBOARD FOR A WARNING SIGNAL, THERE WEREN'T ANY WARNING LIGHT'S DISPLAYED.I JUST RECENTLY HAD REAR BRAKE WORK DONE AND I'M NOT SURE IF THAT IS THE PROBLEM. ALSO, I HAVE BEEN NOTICING A LOUD PITCHED WHISTLING SOUND THAT STARTS AT ABOUT 20 MPH AND STOPS AT ABOUT 45 MPH. THERE IS A RATTLING NOISE THAT ACCOMPANIES THE WHISTLING SOUND WHEN THE CAR IS IN ACCELERATION. *TR

I BOUGHT THIS CAR USED AND DISCOVERED THAT I COULDN'T FILL THE GAS TANK MORE THAN 1/3 OF THE WAY OR IT WOULD LEAK FROM A CRACK IN THE PLASTIC GAS TANK WHERE THE FILLER PIPE CONNECTS TO THE TANK. I LOOKED IT UP ON THE INTERNET AND DISCOVERED IT WAS A COMMON PROBLEM; HTTP://WWW.ABOUTAUTOMOBILE.COM/COMPLAINT/2003/CHEVROLET/VENTURE/FUEL+TANK I TALKED TO MY LOCAL CHEVROLET DEALER AND HE SAID THAT THERE WAS A RECALL, BUT MY VIN NUMBER WAS NOT INCLUDED. NOW WHAT? *TR

THE VEHICLE RANDOMLY SHUTS DOWN COMPLETELY WHILE DRIVING - ALL ELECTRICAL SYSTEMS GO OFF. AFTERWARD, IT CRANKS BUT DOES NOT START, AFTER IT'S TOWED, IT EVENTUALLY STARTS. NO ERROR CODES SHOW IN DIAGNOSTICS. *JS