2005 Ford Expedition

Engine Missing

The contact owns a 2005 Ford Expedition. The contact stated that while driving at an undisclosed speed, the vehicle made an abnormal sound. The vehicle was taken to an independent mechanic, where the contact was notified of an engine misfire. The spark plugs were replaced. Additionally, the contact stated while driving 55 MPH, the brake pedal became stiff, and the vehicle failed to immediately stop. Additionally, the vehicle made an abnormal sound and stalled. The vehicle was taken to an independent mechanic, who informed the contact that the spark plugs, and the engine needed to be replaced. The manufacturer was made aware of the failure and referred the contact to file a complaint with the NHTSA Hotline. The failure mileage was approximately 89,000.

COOPER TIRES 265/70/17 DISCOVERER M+S. BELT SEPARATION AND TIRE DEFORMITY ON 3 OF 4 TIRES IN THE LAST 1000 MILES. 2 FAILED WITHIN THE LAST 200 MILES. IN MOTION, HIGHWAY. . SEVERE VIBRATION OCCURRED. (THINK PAINT MIXER) LOW USE 80% TREAD REMAINS. MAX USE OF 3K MILES PER YEAR BUT NOT ALL YEARS. PURCHASED IN 2013. DOT RM1Y C6J 2412 COOPER CUSTOMER SERVICE CLAIMS I DIDN'T USE THEM ENOUGH. *TR

MY TRUCK LOST ALL FORWARD GEARS EXCEPT FOR REVERSE OUT OF THE BLUE THE OTHER MORNING WHEN ATTEMPTING TO LEAVE HOME. VALVE BODY, SERVOS, SOLENOIDS, HAVE BEEN REPLACED AND STILL HAS NOT CORRECTED THE ISSUE. THE VEHICAL HAS LESS THEN 155000 MILES

ENGINE MAKES RATTLING NOISE AND MISSING BADLY

MY CAR AT TIMES WILL GIVE A HARD START. TURNING, BUT NOT FULLY TURNING OVER OR GIVES OFF A SOUND THAT I CAN ONLY DESCRIBE AS AN ELEPHANT TRUMPETING. WHEN IT DOES START AT TIMES IT WILL SHUT COMPLETELY OFF JUST AS FAST. IT HESITATES TO PICK UP ADEQUATE SPEED AND WILL STUMBLE OR JERK, AND WHEN PUT IN REVERSE IT WILL COMPLETELY STALL OUT. I'VE HAD A NEW BATTERY INSTALLED, AND THE SPARK PLUGS AND BOOTS HAVE BEEN CHANGED, BUT TO NO AVAIL.

THE CAR TURNS OFF. I NEED TO PUT THE CAR IN PARK WAIT A FEW MINUTES THEN TURN THE CAR BACK ON AND IT WORKS. THE BAD THING IS IT CAN HAPPEN AT ANY TIME.

I WAS DRIVING AND ALL OF A SUDDEN STEERING WHEEL LOCKED AND MY CAR LITERALLY SHUT OFF WHILE I WAS DRIVING.. I COASTED TO THE SIDE AND I TURNED OFF CAR.. TRIED TO TURN IT BACK ON AND IT KEPT CRANKING AND I KEPT DOING IT LIKE 5 TIMES UNTIL IT STARTED BACK UP. SURE IT IS A 2005, BUT IT HAS BEEN GIVING ME PROBLEMS SINCE I GOT IT, NOW IT IS WORSE. I DON'T BELIEVE IT IS WEAR AND TEAR I ACTUALLY REPLACED THE WHOLE ENGINE 4 YEARS AFTER I BOUGHT MY CAR WHICH IS RIDICULOUS TO BEGIN WITH. IF MY CAR BURNS UP WHILE I AM DRIVING I WILL REALLY MAKE A STINK..

CRANK NO START, AFTER REPLACED NEW FUEL PUMP, FILTER AND OTHER PARTS WOULD NOT START AND NOT GETTING FUEL. WAS IN MOTION AND DIED AFTER MAKING A RIGHT TURN AFTER FILLING FUEL TANK.

MY GEAR SHIFT BROKE WHICH BROKE THE STEERING COLUMN AND I FEEL LIKE THIS IS DEFAULTED SYSTEM SO DO FORD BECAUSE DID CONTINUE THIS STEERING COLUMN SO I HAD TO REPLACE IT WITH ONE FROM JUNK YARD SO HOW IS THAT SAFE FOR ME AS A CONSUMER WELL I FILING THIS JUST IN CASE IT BREAK AGAIN AND MY LIFE IS IN DANGER MY CAR CAME OUTTA OF PARK LIKE TO TANNED ME OVER SO I'M SPEAKING UP BECAUSE THIS PUT MY LIFE IN DANGER

ALUMINUM BODY PANELS ARE CORRODING UNDERNEATH THE PAINT, CAUSING BUBBLING, FLAKING, AND CHIPPING OF THE PAINT. THIS IS NOT CAUSED NATURALLY, THIS IS A FAILURE ON THE PART OF FORD AND THEIR QUALITY CONTROL. THE ALUMINUM UNDERNEATH WAS CONTAMINATED FROM THE FACTORY WITH IRON CAUSING CORROSION. WHILE KNOWING ABOUT THIS PROBLEM, THEY FAILED TO ISSUE A RECALL.

TL* THE CONTACT OWNS A 2005 FORD EXPEDITION. THE CONTACT STATED THAT WHILE DRIVING AT 65 MPH, THE FUEL CAP AND THE TIRE SENSOR WARNING LIGHT ILLUMINATED. THE VEHICLE WAS TAKEN TO THE DEALER (CAPITAL FORD OF CHARLOTTE LOCATED AT 5411 N TRYON ST, CHARLOTTE, NC 28213) WHERE IT WAS DIAGNOSED THAT THE TIRE SENSOR, THE FUEL CAP AND THE WINDSHIELD WIPER BLADE NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED. THE CONTACT STATED THAT THE FUEL CAP WARNING LIGHT, FAILURE OCCURRED EVEN AFTER REPLACING THE PART. THE MANUFACTURER WAS NOT CONTACTED AND WAS NOT MADE AWARE OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 94,368.

THE PAINT IS PEELING ON THE EXTERIOR AND INTERIOR IN LARGE PATCHES FOR NO OBVIOUS REASONS INCLUDING RUST OR ENVIRONMENTAL FACTORS LIKE BEING CLOSE TO SALT WATER. THE PEELING PAINT IS PRIMARILY ON THE BACK HATCH BUT ALSO SOME PAINT BUBBLING IS OCCURRING ON A FEW OTHER SMALL SPOTS ON THE VEHICLE. THERE IS ALSO EVIDENCE OF SIGNIFICANT LEAKS OF WATER INTO THE BODY BUT NO OBVIOUS POINTS OF ENTRY.

FUEL PUMP DRIVER MODULE FAILED DUE TO DESIGN FLAW WHICH CAUSED GALVANIC CORROSION. ALUMINUM BODY OF COMPONENT ACTS AS THE SACRIFICIAL ANODE FOR THE FRAME WHICH IS STEEL. THIS CAUSED MY VEHICLE TO STALL AT 65MPH AND LOSE POWER AND THUS CAUSED THE LOSS OF POWER STEERING AND HYDRAULIC BRAKE BOOSTER WHILE TRAVELING A HIGH RATE OF SPEED. THIS COULD BE ESPECIALLY DANGEROUS ON HIGHWAYS, CONGESTED AREAS, OR AREAS WITH PEDESTRIANS SUCH AS SCHOOLS. I HAVE ALSO NOTIFIED FORD OF THIS PROBLEM.

VEHICLE VIBRATES BADLY ESPECIALLY AT HIGHWAY SPEEDS. VIBRATION IS SO BAD, THE VEHICLE ROCKS SIDE-TO-SIDE WHILE DRIVING. DRIVING AT HIGHWAY TURNPIKE SPEED OF 75MPH, VEHICLE ENGINE BEGAN TO SURGE AND THEN COMPLETELY SHUT DOWN. OIL PRESSURE GAUGE INDICATED LOW OIL PRESSURE AND VEHICLE WOULD NOT START. VEHICLE STILL HAD ELECTRICAL FUNCTION BUT ENGINE NO LONGER WOULD TURN OVER. CHECKED ENGINE OIL LEVEL AND HAD ENGINE OIL. CALLED HIGHWAY PATROL AND HAD TO HAVE THE VEHICLE TOWED. *TR

TWICE I'VE BEEN DRIVING AND ALL OF A SUDDEN I LOST POWER AND "ELECTRONIC THROTTLE CONTROL" MESSAGE CAME ON. ACCELERATOR WOULD NOT WORK, COASTED TO THE SIDE OF THE ROAD-- 2ND TIME IN HEAVY TRAFFIC!! BOTH TIMES I TURNED OFF ENGINE AND RESTARTED OK, BUT I'M SCARED TO DEATH TO DRIVE WITH MY CHILDREN IN THE CAR. DRIVING STRAIGHT ON CITY STREET BOTH TIMES. *TR

TL* THE CONTACT OWNS A 2005 FORD EXPEDITION. WHILE DRIVING 30 MPH, THE VEHICLE VIBRATED ABNORMALLY AND THE CHECK ENGINE WARNING INDICATOR ILLUMINATED. THE VEHICLE WAS TAKEN TO THE DEALER WHERE IT WAS DIAGNOSED THAT THE ENGINE NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 120,000. THE VIN WAS NOT AVAILABLE.

THIS CAR JUST NUMEROUS OF PROBLEM..... WHO EVER BUILT THIS CAR DID NOT HAVE A GOOD JOB OF DOING IT

MY SUV WAS PARKED IN PARKING LOT OF A STORE. SMOKE STARTED COMING OUT FROM MY VEHICLE. THEN IT STARTED TO CATCH ON FIRE. FIRE FIGHTERS SAID THE FIRE STARTED FROM THE FUEL INJECTORS.

TAKATA RECALL. MY FORD EXPEDITION 2005, HAS BEEN MESSING UP FOR A WHILE NOW. WE'VE TAKEN IT TO THE MECHANIC WAY TOO MANY TIMES. IT STARTS SHAKING SOMETIMES WHEN WE STEP ON THE GAS AFTER WE STOP AT A STOP LIGHT OR STOP SIGN, AND GOING UP A HILL IT FEEL A LIKE IT HESITATES AND FEELS AS IF IT'S PULLING BACK. YESTERDAY WAS WHAT STARTED TO CONCERN ME THOUGH. MY VEHICLE JUST SHUT OFF ON ME COMPLETELY WHILE I WAS ON THE HIGHWAY. MY FORD FOCUS 2012 HAS BEEN DOING THE SAME THING AND IT TURNS OUT IT HAD A RECALL ISSUE, SO I WAS WONDERING IF THAT'S THE CASE WITH MY EXPEDITION.