2001 Ford F-650
The Verdict
The 2001 Ford F-650 has 9 owner complaints filed with NHTSA. The most reported issues are transmission (6 complaints) and body (1 complaints). With a Klunk Score of 98/100, it earns a "Smooth Ride" rating. If you're shopping for a Ford F-650, consider the 2012 model year which has 88% fewer complaints.
Safe Bet
The 2012 has 88% fewer complaints
View the 2012 Ford F-650 dashboard →
Klunk Score: Smooth Ride
This vehicle year has significantly fewer complaints than average. A reliable choice.
How is this calculated?
The Klunk Score ranks this vehicle year against all others in our database based on total owner complaints filed with NHTSA. 100 = fewest complaints (top tier), 0 = most complained-about. Scores above 60 are better than average; below 40 means more problems than most.
Get notified if a recall hits this car.
We email you when NHTSA issues a new recall on the 2001 Ford F-650. No spam, no marketing.
Under the Hood
Each number is a complaint. Darker = bigger problem.
By Category
By Severity
Worst Problems
Complaints
TL* THE CONTACT OWNS A 2001 FORD F-650. WHILE DRIVING AT VARIOUS SPEEDS, EXHAUST FUMES EMITTED INTO THE CABIN OF THE VEHICLE. THE FAILURE RECURRED CONTINUOUSLY. THE VEHICLE WAS NOT TAKEN TO A DEALER OR DIAGNOSED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 246,000.
TL*THE CONTACT OWNS A 2001 FORD F650. WHILE DECELERATING AT 5 MPH, THE BRAKES MADE A GRINDING NOISE. THE CONTACT NOTICED THAT THE REAR INSIDE DISC ROTORS SHOWED SIGNS OF METAL AGAINST METAL WEAR. HE STATED THAT THE INBOARD DISK PAD HAD ALMOST WORN COMPLETELY THROUGH THE DISK ROTOR. THIS COULD HAVE CAUSED THE PISTON SEALS TO FAIL AND RELEASE ALL OF THE BRAKE FLUID. THE VEHICLE WAS NOT TAKEN TO A DEALER. THE CURRENT MILEAGE WAS 51,700 AND FAILURE MILEAGE WAS 51,650.
WHILE DRIVING IT WAS HARD TO SHIFT GEARS. DEALERSHIPS MECHANIC INFORMED THE CONSUMER THAT THE PROBLEM PERTAINED TO TRANSMISSION FAILURE. *AK
SINCE OWNERSHIP OF THE VEHICLE CONSUMER REPLACED THE CLUTCH MASTER CYLINDER SEVEN TIMES. FRONT AXLE WAS REPLACED ONCE. WHILE DRIVING AT ANY SPEED THE GEARS WERE NOT SHIFTING PROPERLY. DEALER REPLACED THE OLD TRANSMISSION WITH A NEW ONE. *AK
SINCE THE PURCHASE OF OUR 2001 FORD F650, WE HAVE HAD CONTINUAL PROBLEMS THAT ARE THE OBVIOUS RESULT OF A MANUFACTURER'S DEFECT. NOT ONLY HAS THIS PROBLEM COST US MONEY, BUT WE BELIEVE THAT IT IS A SAFETY RISK THAT CANNOT BE IGNORED. THE CLUTCH ITSELF WILL FAIL ON THE TRUCK IN THE MIDDLE OF TRAFFIC. THE EXACT PROBLEM LIES IN THE CLUTCH CYLINDER, WHICH, WE HAVE REPLACED AN AMAZING FIVE TIMES. AFTER TALKING WITH DEALERS OF THIS TRUCK AND RESEARCHING OTHERS WHO HAVE PURCHASED THIS TRUCK FOR COMMERCIAL USE, WE HAVE FOUND THAT THEY ARE HAVING THE SAME PROBLEMS. NOT ONLY HAVE WE HAD PROBLEMS WITH THIS PARTICULAR TRUCK, BUT THE SAME EXACT PROBLEM IS HAPPENING WITH ANOTHER 2001 F650 THAT WE PURCHASED AT THE SAME TIME. DUE TO THESE CONTINUAL PROBLEMS WITH THE CLUTCH, WE WERE FORCED TO HAVE THE TRANSMISSION REBUILT. NOT ONLY WAS THIS COSTLY, BUT THERE IS NO WAY TO PREVENT US FROM CONTINUING TO REPLACE OUR CLUTCH CYLINDER AND EVENTUALLY REPLACING THE TRANSMISSION ONCE AGAIN. WHEN THE CLUTCH FAILS ON THE HIGHWAY, IT BECOMES DIFFICULT IN THE MIDDLE OF A BUSY INTERSTATE TO STEER THE TRUCK OFF THE ROAD. WE ARE CONSTANTLY DELIVERING TO BUSY METROPOLITAN AREAS, AND WE PURCHASED THIS TRUCK WITH THE IDEA THAT IT WAS COMPLETELY SAFE. HOWEVER, THE CLUTCH CONTINUES TO FAIL, AND THE REPLACEMENT PARTS, TOO, ARE DEFECTIVE. *JB
TRUCK UNSAFE TO OPPERATE BECAUSE OF STALLING AND TRUCK WILL RUN AWAY DOWN HILL AND WILL PULL VEHICLE WHEN AT IDLE SETTING STILL.*AK
HYDRAULIC CYLINDER CLUTCH PEDAL MALFUNCTIONED, CAUSING VEHICLE TO ACCELERATE WHEN APPLYING BRAKES. DEALER HAS REPLACED CYLINDER THREE TIMES. PLEASE PROVIDE FURTHER INFORMATION.*AK
THE CLUTCH PEDAL WENT TO THE FLOOR AND WOULD NOT RETURN, CONSUMER WAS INFORMED THAT THE CLUTCH MASTER CYLINDER HAD FAILED.*JB
CLUTCH HYD. SYSTEM FAILS WITH NO WARNING .CLUTCH WILL NOT DISENGAGE. *AK