2014 Toyota Highlander

The driver’s-side rear spoiler on my 2014 Toyota Highlander Limited AWD has melted, bubbled, and warped. The vehicle has been stored 100% of the time in a fully enclosed garage with no windows since new. It has only 65,000 miles and has received all service exclusively at authorized Toyota dealerships. There has been no direct sun exposure, accident, or misuse. Toyota dealer and Corporate attributed this to “solar convergence” and denied any repair assistance or goodwill coverage. This explanation does not match the facts given the garage setup and minimal outdoor time. This appears to be a materials/design defect in the black plastic spoiler. Similar melting/warping issues are reported by other owners on Highlanders and RAV4s, even on low-mileage garaged vehicles. Dealer replacement quotes are typically $2,700+. I request NHTSA investigate this recurring plastic failure as a potential defect in materials and workmanship. Attachments (upload with form): • Photos of the melted spoiler (multiple angles) I am available for any additional information. 05 May 2026

I noticed the smell of wires burning, a billow of smoke started emitting from the two levers used to heat the seats near the gear shift area. I was on the freeway and immediately pulled to the side of the road, turned off the car and called 911 before any flames were seen. There were no warning signs, lamps or other symptoms until the smell of burning wires and the smoke.

The contact owns a 2014 Toyota Highlander. The contact stated that a hybrid system warning alert was displayed. The vehicle was taken to an independent mechanic, where it was diagnosed and determined that the windshield wiring system had failed and that the windshield needed to be replaced. The vehicle was not repaired. The mechanic informed the contact that the windshield failure was associated with NHTSA Campaign Number: 18E107000 (Electrical System, Visibility). The dealer was not contacted. The vehicle was not diagnosed or repaired. The windshield manufacturer was made aware of the failure; however, the vehicle manufacturer was not made aware of the failure. The approximate failure mileage was 190,000.

Was driving 70 mph on nj 287 when all sudden I hear something that sounded like implosion and air was coming from sunroof. Ended up being sun roof glass flew out of car sunroof frame. Toyota knew it was a defect as they did inspection but did not want to cover it because they said it’s out of warranty. Thankfully no one was driving behind me at that time

Rear lights located both on the tailgate and body of the vehicle. The lights covers failed to remain adhered to the lights themselves and fell off and are partially adhered as a result of what appears to be a failure of the adhesion material . Two light covers may have been lost while driving. Unknown if their loss resulted in damage(s) to others. Without the outer cover results in the exposure of the lights to weather and potential failure. Review with Toyota of Orange service manager confirm the failure of adhesive/ manufacturing process of the lights

Installed (4) Firestone Destination Le3 tires in March 2022. All four tires became dry rot in just over 2 years, failed inspection at 2 1/2 years. 70,000 mile tires with roughly 28,000 miles left of the warranty.

Water leaks inside the car every time it rains. We checked the sunroof drain tubes. They are clear. It is getting in through the roof rail bolts. It runs down the pillars to the floor and underneath the floor carpet. The carpet is wet for long periods of time in rainy seasons. I am concerned there is going to be mold issues.

The vehicle is painted in Blizzard Pearl, which has a known peeling issue. Toyota never sent us any notification of an issue with the paint. A patch of the paint has peeled off of the top of the vehicle and has continued to grow larger. When we contacted Toyota, we were informed the period to fix this issue has closed and we would have to repair out of pocket. Our vehicle was mostly garage kept and didn't suffer the immediate failure of the paint. Blizzard Pearl is a color with an additional cost and has the most complaints for failure. Toyota has acknowledged the problem but did very little to ensure customers were notified, did not take into account Blizzard Pearl painted vehicles would fail at different times due to climate/storage of vehicles, and only provided a narrow window to their customers for this issue. The peeled paint has exposed the body of the vehicle to the elements, which will cause it to rust.

The contact owns a 2014 Toyota Highlander. The contact stated while driving approximately 40 MPH, the moon roof detached from the vehicle. There was no warning light and there was no impact to have caused the failure. There were no reported injuries. The local dealer had previously replaced a piece on the moon roof. The vehicle was taken to the local dealer, where it was diagnosed that the moon roof glass needed to be replaced. The vehicle was repaired. The manufacturer was contacted, but no additional assistance was provided. The approximate failure mileage was 99,000.

The lift gate will not open and close properly. It only works about 5% of the time.

The contact owns a 2014 Toyota Highlander. The contact stated that the tailgate failed to open and close properly or as needed. The vehicle was taken to an independent mechanic, who referred the contact to file a complaint with the NHTSA Hotline. The manufacturer was made aware of the failure. The failure mileage was approximately 87,000.

Some doors do not lock when the electric lock switch is pressed on the FOB or using the button on the door. Sometimes the doors that did lock don’t the next time. This is a security issue while driving the vehicle and another security issue when parking. It’s also a safety issue for the same reasons. The door’s electrical locking system fails and needs to be fixed.

As other 2014 Toyota highlander: issues with the power liftgate/rear door. Have problems open and closing the rear door to the point that it's not working properly anymore. Toyota is not responding unless you pay around $4,000 to get it fix.There are plenty of cases like mine and for the 2010-2023 they had a class action suite for the same problem, resulting in a mass recall to correct the problem. Why is not a recall for this year as well.

The glass from the panoramic sunroof detached from the vehicle while traveling approximately 60 MPH.

While driving car started singing and message came on dashboard about idling will cause the engine to turn off then the car turned off while I was driving it has happened multiple other times even after taking it to the dealership twice and then doing an update on it

On or about 12-01-2022 the windshield wipers stopped functioning. The result was an inability to drive the car in the rain and especially at night. It was impossible to see so we pulled over and waited for the rain to stop. After analyzing the issue the motor had failed. We contacted Toyota for a replacement motor. What we found: No wiper motors are available from Toyota, no aftermarket parts are available. We ordered a motor from Gladstone Toyota but after a couple of weeks began calling. What I was told: no wiper motors are available and there is no release date for when they will be. I began calling around and found that some dealers (TRD Shop) have over 200 on back order and only 80 were released last time they made them. where we are today: We have a vehicle made by Toyota that is unsafe to operate due to the fact the wipers don't work We replaced the wiper switch $232.00 but that only allowed the rear wipers to function further inspection verified the front wiper motor failed in conjunction with the switch that controls the rear wipers. I contacted Toyota engagement center and reported the issues. case #230106000756 they told us they would have a parts specialist contact us no later than 01-09-23 that never happened ans on 01-10-23 I contacted them to let them know we haven't heard anything. They have yet to reply or contact us regarding our back order. We purchased the vehicle new from Gladstone Toyota all maintenance done there. Issue is the vehicle is unsafe to drive in Oregon in the middle of winter, Parts are not available to repair Toyota unwilling to reply or see what they can do for us using their online engagement website.

Hi, the stereo sound on My Toyota highlander keep going in and out, I can start the car in the morning and the radio will work no problem but if I turn off the car or the radio sound or music will go away. after the car is off for about 3 to 4 hours period of time the sound will come back on when the vehicle is turned back on. This is the original Stereo system. Thank You

Steering column locked on several occasions while driving. Electrical systems blink on and off. Exactly as described in NHTSA recall #15V144000 and as far I can tell the exact same part number.

rear tailgate door non-functioning. auto door button does not work and door cannot be opened manually. serious safety issue if car in accident and side doors won't open. checked by dealer in dec. 2020, and they knew about problem and not covered under warrranty. toyota knew about problem in march 2016 and issued service bulletin T-SB-0023-16 which clearly states problem and how to fix in 8 pages.; and only covers 2014/2015 highlanders under warranty. no warning lights; tailgate failed in dec. 2020. vehicle only inspected by toyota dealer in roseville, CA. if Toyota is willing to fix some highlanders, why would they exclude others out of warranty? This makes the vehicle unuseable for a family that hikes, camps, plays sports, etc. and I feel is a clear safety issue if one exit out of vehicle does not operate!

The contact owns a 2014 Toyota Highlander. The contact stated while opening the hatchback, the hatchback failed to fully open as needed. The vehicle was taken to the dealer and the contact was informed that the support struts needed to be replaced. The vehicle was not repaired. The manufacturer was not contacted or informed of the failure. The approximate failure mileage was 43,000.